$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Genuine Saab 4cyl Oil Filters
1 x Exhaust Clamp Kit
1 x Flex Pipe 900 94-98 9-3 99-02
3 x Oil Cap GM "HHR"
2 x Oil Filter Re-locator
2 x Flywheel Twin Disk 7.25in B2xx
2 x Slave Cyl
2 x ARP Ring Gear Bolts F25/F35
1 x Aluminum Flywheel For NG900/9-3
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x T7 Injector Spacer Kit
1 x Oil Cooler Adaptor B2X5
1 x Viggen Fog Air Intake
2 x Turbo Conversion Pipe 900 9-3 T5
1 x PPC - Upgrade from stage 1 to stage 3
1 x MTF0063 Manual Gear oil
1 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
1 x Shifter Alignment Pins (Set 2)
1 x Replacement V6 Coolant Cap
1 x T7 Head Plug NGK
2 x Troll Head Plug
1 x B207 Coolant Cap
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x PPC 3 Volvo Diagnostic System
1 x Fog light 9-3 Right 99-00
1 x 20th Viggen logo Shifter Top
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Clear Little Fender Blinkers Factory Saab
1 x Fog light 9-3 left 99-00
1 x 9-3 ng900 radio wires
1 x Adaptor Harness Handsfree 01-
1 x Griffin logo Shifter Top
1 x 9-3 Rear Ashtray
1 x Coreganizer
1 x Antenna Plug NG900/9-3 hatchback
1 x 9-3/NG900 Shift Knobs Leather
1 x Saab black Keychain
1 x Viggen Titanium KeyChain
1 x 9-5 Aero Sill Protection
1 x BSR 9-5 260Hp 2006-
2 x Viggen Clutch Kit 99-02
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x BSR Optiflow Intake V6 2.8t
2 x JE Piston Rings 90.0mm 235/205
2 x Rod Bearings only Pauter Rods
1 x BSR Optiflow Intake 4cyl
1 x Head Stud Kit all 4cyl
2 x Shifter Top Ghost Logo
1 x Headbolts (New Style)
1 x Upgrade Valve Springs T5 Cars
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Balance Shaft Tensioner Delete
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Shift Rod Bushings
1 x Throttle Bend for T5 94-99
1 x Transmission Nut F35 F25
1 x T7 3.5 Bar Fuel Pressure Regulator
$11,606.49
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail