$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x 9-3 / 900 Uprated Front ARB Bushings
2 x Basic Subframe Brace
1 x Steering Coupler 9-3 99-02
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Exhaust manifold Stud Kit
2 x Exhaust Clamp Kit
3 x Flex Pipe 900 94-98 9-3 99-02
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Cat back for Viggen 2.5in
1 x PPC - Upgrade from stage 1 to stage 3
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Genuine Saab 4cyl Oil Filters
2 x Downpipe Hardware Kit
2 x Crush Sleeve F35 F25
1 x Rear Engine Mount 4cyl
1 x Remote Button NG900
3 x Replacement Hardware Pack 6-Point
1 x Direct Ignition T5 RED
1 x Crank Vent Kit #6 T7 4cyl
1 x Replacement Filter for Open air 9-3 T7
2 x Mass Airflow Meter T7
1 x Fuel Line Clip
1 x Direct Ignition T7 Black
1 x AEM Wideband Gauge Kit
1 x Fuel Pressure Regulator 4.0 bar
1 x Rivetnuts Pair (2pcs)
2 x 9-3 Rear Ashtray
1 x 9-3/NG900 Shift Knobs Leather
1 x Coreganizer
1 x Griffin logo Shifter Top
1 x c900 Performance Brake lines
1 x 9-3 ng900 radio wires
3 x Adaptor Harness Handsfree 01-
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x ARP Ring Gear Bolts F25/F35
1 x Oil Cooler Adaptor B2X5
1 x Con Rods V6 2.8L 155.8mm
1 x Troll Head Plug
1 x B207 Coolant Cap
1 x 9000 Shifter Bushing Repair Kit
2 x Head Stud Kit all 4cyl
1 x Antenna Plug NG900/9-3 hatchback
1 x 9-3 ng900 Hood Protection Strip
1 x Machined Control Arm Kit
1 x Steering Rod Bushings NG900/93
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x BBS Center Cap for 9-2x RK small caps
1 x Headbolts (New Style)
1 x Floormats BSR 9-5
1 x PPC 3 Volvo Diagnostic System
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Head Bolt Washers
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Oil Cap 9-3SS V6 "Griffin"
$8,876.98
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail