$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x JE Piston Rings 90.0mm 235/205
1 x Balance Shaft Tensioner Delete
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Head Stud Kit all 4cyl
3 x Exhaust Clamp Kit
2 x Rear Engine Mount 4cyl
3 x Flex Pipe 900 94-98 9-3 99-02
1 x Mass Airflow Meter T7
2 x Downpipe Hardware Kit
3 x Oil Cooler Adaptor B2X5
2 x Turbo Conversion Pipe 900 9-3 T5
3 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x T7 Injector Spacer Kit
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Troll Head Plug
1 x Con Rods V6 2.8L 155.8mm
1 x 9000 Shifter Bushing Repair Kit
1 x Replacement V6 Coolant Cap
1 x Limit Strap Coilover Add On Kit
1 x T7 Head Plug NGK
2 x SCNA Christmas Calendar
1 x B207 Coolant Cap
2 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x MTF0063 Manual Gear oil
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 ng900 Hood Protection Strip
1 x Antenna Plug NG900/9-3 hatchback
1 x Fog light 9-3 left 99-00
1 x 9-3 /NG900 Grille
2 x Clear Little Fender Blinkers Factory Saab
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
1 x PPC - Upgrade from stage 1 to stage 3
1 x c900 Performance Brake lines
1 x PPC 3 Volvo Diagnostic System
1 x ARP Ring Gear Bolts F25/F35
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Rear spring perches Adjustable NG900/9-3
1 x Machined Control Arm Kit
1 x Saab black Keychain
1 x Rear Camber Shims Kit 6pcs
1 x Upgrade Valve Springs T5 Cars
1 x Crush Sleeve F35 F25
1 x Fuel Line Clip
1 x Crank Vent Kit #6 T7 4cyl
1 x Turbo Bypass Valve
1 x Shifter Mount Kit Cobalt/ HHR
1 x Remote Button NG900
1 x Basic Subframe Brace
1 x Viggen Fog Air Intake
1 x BBS Center Cap for 9-2x RK small caps
$7,538.78
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail