$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Basic Subframe Brace
6 x 9-3 / 900 Uprated Front ARB Bushings
3 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 4340 Connecting Rods B204 B235
2 x Balance Shaft Tensioner Delete
1 x Flywheel Twin Disk 7.25in B2xx
1 x Aluminum Flywheel For NG900/9-3
2 x ARP Ring Gear Bolts F25/F35
2 x Slave Cyl
1 x Shifter Top Ghost Logo
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Rear Engine Mount 4cyl
3 x Transmission Nut F35 F25
1 x Quaife Differential 9-5 and Viggen (F35)
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x 20th Viggen logo Shifter Top
1 x Coreganizer
1 x SCNA Christmas Calendar
1 x 9-3 ng900 radio wires
1 x Viggen Titanium KeyChain
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 Rear Ashtray
1 x Adaptor Harness Handsfree 01-
1 x Saab black Keychain
1 x Griffin logo Shifter Top
1 x 9-3/NG900 Shift Knobs Leather
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x T7 Injector Spacer Kit
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Oil Cooler Adaptor B2X5
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Viggen Fog Air Intake
1 x Oil Cap GM "HHR"
1 x Short Shifter HHR Cobalt F35 F40
1 x Shifter Mount Kit Cobalt/ HHR
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Throttle Bend for T5 94-99
2 x Rear Camber Shims Kit 6pcs
2 x Rear spring perches Adjustable NG900/9-3
2 x Machined Control Arm Kit
1 x Steering Coupler 9-3 99-02
1 x Limit Strap Coilover Add On Kit
1 x T5 3.0 Bar Map Sensor Adaptor
1 x AEM Wideband Gauge Kit
1 x IAT Weld Bung T5/Bosch
1 x Fog light 9-3 Right 99-00
1 x PPC 3 Volvo Diagnostic System
1 x 9-5 Open Air Prefilter
1 x V6 Tank Float - SparePart
1 x 9-3 SS Akebono Rear Pads
1 x Oil Filter Re-locator
1 x Headbolts (New Style)
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Head Stud Kit all 4cyl
1 x Troll Head Plug
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Rod Bearings only Pauter Rods
1 x T7 Head Plug NGK
1 x BBS Center Cap for 9-2x RK small caps
1 x Viggen Clutch Kit 99-02
$10,430.95
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail