$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Throttle Bend for T5 94-99
4 x Open Air Intake 9-3 00-02 and Viggen (All T7)
6 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x 9-5 Intercooler ETS
1 x PPC 3 Volvo Diagnostic System
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
3 x Oil Cooler Adaptor B2X5
2 x 9-3 ng900 Hood Protection Strip
1 x 9-3 /NG900 Grille
1 x Fog light 9-3 Right 99-00
1 x Fog light 9-3 left 99-00
1 x Antenna Plug NG900/9-3 hatchback
1 x Clear Little Fender Blinkers Factory Saab
1 x Fog light Replacement Panels
1 x Rear Engine Mount 4cyl
1 x Remote Button NG900
1 x Direct Ignition T5 RED
1 x Replacement Hardware Pack 6-Point
1 x Crush Sleeve F35 F25
1 x Downpipe Hardware Kit
1 x Direct Ignition T7 Black
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Crank Vent Kit #6 T7 4cyl
1 x Genuine Saab 4cyl Oil Filters
1 x Exhaust Clamp Kit
1 x Replacement Filter for Open air 9-3 T7
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Fuel Line Clip
1 x Mass Airflow Meter T7
1 x Limit Strap Coilover Add On Kit
1 x Troll Head Plug
1 x Oil Filter Re-locator
1 x K&N Filter Service Kit
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Oil Cap GM "HHR"
1 x Shifter Mount Kit Cobalt/ HHR
1 x Short Shifter HHR Cobalt F35 F40
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-5 Open Air Prefilter
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Saab black Keychain
1 x SCNA Christmas Calendar
3 x T7 3.5 Bar Fuel Pressure Regulator
1 x V6 Tank Float - SparePart
2 x Turbo Conversion Pipe 900 9-3 T5
2 x AEM Wideband Gauge Kit
1 x Replacement V6 Coolant Cap
1 x Moog Ball Joint
1 x Upgrade Valve Springs T5 Cars
1 x Rivetnuts Pair (2pcs)
1 x Viggen Titanium KeyChain
1 x Fuel Pressure Regulator 4.0 bar
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x 9-3 SS Akebono Rear Pads
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Air Filter 06 version (All 9-5)
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Shift Rod Bushings
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Coreganizer
1 x Griffin logo Shifter Top
1 x 9-3 Rear Ashtray
1 x Injectors Siemens 60lb 630cc (set 4)
1 x 9000 Intercooler ETS
1 x MTF0063 Manual Gear oil
1 x Viggen Fog Air Intake
$13,270.75
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail