$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Moog Ball Joint
1 x AEM Wideband Gauge Kit
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Throttle Bend for T5 94-99
2 x Map/MAT sensor weld bung
1 x Rivetnuts Pair (2pcs)
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x IAT Weld Bung T5/Bosch
2 x PPC - Upgrade from stage 1 to stage 3
1 x Universal / Special Request
2 x Viggen Fog Air Intake
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Fuel Pressure Regulator 4.0 bar
1 x ATF Saab 3309 (Automatic 02->)
1 x Shifter Alignment Pins (Set 2)
2 x MTF0063 Manual Gear oil
1 x 9-3 ng900 Hood Protection Strip
1 x Antenna Plug NG900/9-3 hatchback
1 x Fog light 9-3 Right 99-00
1 x Fog light Replacement Panels
1 x Fog light 9-3 left 99-00
1 x Clear Little Fender Blinkers Factory Saab
1 x 9-3 /NG900 Grille
1 x Viggen Titanium KeyChain
1 x Saab black Keychain
2 x SCNA Christmas Calendar
1 x T7 Head Plug NGK
1 x Headbolts (New Style)
1 x Rod Bearings only Pauter Rods
1 x Oil Filter Re-locator
1 x Head Stud Kit all 4cyl
1 x 4340 Connecting Rods B204 B235
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Slave Cyl
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Aluminum Flywheel For NG900/9-3
1 x BSR Optiflow Intake 4cyl
1 x BSR Optiflow Intake 4cyl w SAI
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x BSR 9-5 260Hp 2006-
1 x BSR 9-5 2010-2011 V6 300Hp
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x Con Rods V6 2.8L 155.8mm
1 x Cat back for Viggen 2.5in
1 x 9000 Intercooler ETS
1 x 9-5 Aero Sill Protection
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Weld Bungs -Taper- Race Only
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Oil Cooler Adaptor B2X5
$12,163.72
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail