$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Steering Rod Bushings NG900/93
2 x Machined Control Arm Kit
3 x Limit Strap Coilover Add On Kit
3 x Rear Camber Shims Kit 6pcs
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Downpipe Hardware Kit
1 x Direct Ignition T7 Black
2 x Mass Airflow Meter T7
1 x Crank Vent Kit #6 T7 4cyl
2 x Crush Sleeve F35 F25
2 x Exhaust Clamp Kit
1 x Direct Ignition T5 RED
1 x Genuine Saab 4cyl Oil Filters
1 x Rear Engine Mount 4cyl
2 x Flex Pipe 900 94-98 9-3 99-02
1 x PPC 3 Volvo Diagnostic System
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x 9-3 /NG900 Grille
1 x Antenna Plug NG900/9-3 hatchback
2 x Fuel Pressure Regulator 4.0 bar
2 x Injectors Siemens 60lb 630cc (set 4)
2 x IAT Weld Bung T5/Bosch
1 x AEM Wideband Gauge Kit
2 x Injectors Green Giant 42lb (set 4)
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Shifter Alignment Pins (Set 2)
1 x MTF0063 Manual Gear oil
1 x Turbo Conversion Pipe 900 9-3 T5
1 x K&N Filter Service Kit
1 x T7 Injector Spacer Kit
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Throttle Bend for T5 94-99
1 x Viggen Fog Air Intake
1 x Oil Cooler Adaptor B2X5
1 x ATF Saab 3309 (Automatic 02->)
1 x 20th Viggen logo Shifter Top
1 x 9-3 ng900 radio wires
1 x Saab black Keychain
1 x Head Stud Kit all 4cyl
1 x 4340 Connecting Rods B204 B235
1 x Headbolts (New Style)
1 x JE Piston Rings 90.0mm 235/205
1 x Rod Bearings only Pauter Rods
1 x c900 Performance Brake lines
1 x Open Air Intake 9000 93-98
2 x Shift Rod Bushings
1 x 9000 High Performance Brake Line Kit '95-'98
1 x 9-5 Aero Sill Protection
1 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9000 Shifter Bushing Repair Kit
1 x Clear Little Fender Blinkers Factory Saab
1 x Rear spring perches Adjustable NG900/9-3
2 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Mat Set Black Rubber 9-5 10-
1 x Mat Set Textile Jet Black 9-5 10-
1 x Mat Set Textile Parchment 9-5 10-
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Mat Set Textile Shark Grey 9-5 10-
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Turbo Bypass Valve
1 x Remote Button NG900
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Universal / Special Request
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Map/MAT sensor weld bung
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Cabin Vent Fan
1 x Downpipe 2.8T FWD (2wd)
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Cigarette Lighter
$13,923.69
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail