$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x T7 Injector Spacer Kit
1 x Rivetnuts Pair (2pcs)
1 x Fuel Pressure Regulator 4.0 bar
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Map/MAT sensor weld bung
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Injectors Green Giant 42lb (set 4)
1 x AEM Wideband Gauge Kit
1 x Intake Flange B2x4 T5
1 x Universal / Special Request
2 x PPC - Upgrade from stage 1 to stage 3
1 x IAT Weld Bung T5/Bosch
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Moog Ball Joint
1 x Injectors Siemens 60lb 630cc (set 4)
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Head Bolt Washers
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Coreganizer
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 ng900 radio wires
1 x 20th Viggen logo Shifter Top
1 x Adaptor Harness Handsfree 01-
1 x 9-3 Rear Ashtray
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cooler Adaptor B2X5
1 x MTF0063 Manual Gear oil
1 x K&N Filter Service Kit
1 x Shifter Alignment Pins (Set 2)
1 x ATF Saab 3309 (Automatic 02->)
1 x 9-3 ng900 Hood Protection Strip
1 x Rear spring perches Adjustable NG900/9-3
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Limit Strap Coilover Add On Kit
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x 9-3 /NG900 Grille
1 x Antenna Plug NG900/9-3 hatchback
1 x Rear Camber Shims Kit 6pcs
1 x Basic Subframe Brace
1 x Fog light 9-3 left 99-00
1 x Steering Rod Bushings NG900/93
1 x Clear Little Fender Blinkers Factory Saab
1 x Steering Coupler 9-3 99-02
1 x Machined Control Arm Kit
1 x Mass Airflow Meter T7
1 x Direct Ignition T5 RED
1 x Replacement Hardware Pack 6-Point
1 x Crank Vent Kit #6 T7 4cyl
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Genuine Saab 4cyl Oil Filters
1 x Exhaust Clamp Kit
1 x Head Stud Kit all 4cyl
1 x T7 Head Plug NGK
1 x Headbolts (New Style)
1 x Oil Filter Re-locator
1 x 4340 Connecting Rods B204 B235
$7,745.11
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail