$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Viggen Fog Air Intake
3 x Forge Bypass Valve Cobalt/HHR TC
3 x PPC 3 Volvo Diagnostic System
2 x Oil Cooler Adaptor B2X5
3 x T7 Injector Spacer Kit
1 x c900 Performance Brake lines
2 x PPC - Upgrade from stage 1 to stage 3
1 x Head Stud Kit all 4cyl
1 x Balance Shaft Tensioner Delete
1 x Headbolts (New Style)
1 x JE Piston Rings 90.0mm 235/205
1 x Rod Bearings only Pauter Rods
1 x T7 Head Plug NGK
1 x 4340 Connecting Rods B204 B235
1 x Oil Filter Re-locator
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Adaptor Harness Handsfree 01-
1 x 9-3/NG900 Shift Knobs Leather
1 x IAT Weld Bung T5/Bosch
1 x Machined Control Arm Kit
1 x Rear Camber Shims Kit 6pcs
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x AEM Wideband Gauge Kit
1 x ATF Saab 3309 (Automatic 02->)
1 x MTF0063 Manual Gear oil
1 x 9-3 ng900 Hood Protection Strip
1 x Fog light 9-3 left 99-00
1 x Aluminum Flywheel For NG900/9-3
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Sport Transmission Mount 9-3/900 (Automatic)
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Quaife Differential 9-5 and Viggen (F35)
2 x SCNA Christmas Calendar
1 x 9000 Shifter Bushing Repair Kit
1 x Con Rods V6 2.8L 155.8mm
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x BSR 9-5 260Hp 2006-
1 x BSR 9-5 3.0T V6 200Hp
1 x Hood Emblem 9-5 All
1 x Slave Cyl
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Coolant Bypass Valve 9-5
1 x Fuel Line Clip
1 x Cigarette Lighter
1 x Mass Airflow Meter T7
1 x Exhaust Clamp Kit
1 x Remote Button NG900
1 x Genuine Saab 4cyl Oil Filters
1 x Shift Rod Bushings
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 20th Viggen logo Shifter Top
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Basic Subframe Brace
2 x T7 3.5 Bar Fuel Pressure Regulator
2 x Throttle Bend for T5 94-99
1 x Midpipe 2.0T 07-11 FWD (2wd)
$11,939.65
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail