$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
6 x Head Bolt Washers
3 x Intake Flange B2x4 T5
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
3 x Map/MAT sensor weld bung
1 x Moog Ball Joint
2 x Injectors Green Giant 42lb (set 4)
2 x PPC - Upgrade from stage 1 to stage 3
3 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Replacement Hardware Pack 6-Point
3 x Genuine Saab 4cyl Oil Filters
3 x Exhaust Clamp Kit
1 x Crank Vent Kit #6 T7 4cyl
3 x Fuel Line Clip
2 x Flex Pipe 900 94-98 9-3 99-02
4 x Mass Airflow Meter T7
1 x PPC 3 Volvo Diagnostic System
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Shifter Alignment Pins (Set 2)
2 x MTF0063 Manual Gear oil
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Aluminum Flywheel For NG900/9-3
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Throttle Bend for T5 94-99
2 x Headbolts (New Style)
1 x Rod Bearings only Pauter Rods
2 x JE Piston Rings 90.0mm 235/205
1 x 4340 Connecting Rods B204 B235
2 x Balance Shaft Tensioner Delete
1 x T7 Injector Spacer Kit
1 x Oil Cooler Adaptor B2X5
1 x Oil Filter Re-locator
3 x T7 3.5 Bar Fuel Pressure Regulator
1 x Viggen Fog Air Intake
1 x T7 Head Plug NGK
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Turbo Conversion Pipe 900 9-3 T5
1 x Head Stud Kit all 4cyl
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x 9-3 Rear Ashtray
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-3 ng900 radio wires
2 x Adaptor Harness Handsfree 01-
1 x 9-3/NG900 Shift Knobs Leather
2 x Griffin logo Shifter Top
1 x Coreganizer
2 x Clear Little Fender Blinkers Factory Saab
1 x Shifter Mount Kit Cobalt/ HHR
1 x Universal / Special Request
2 x Weld Bungs -Taper- Race Only
2 x Throttle Body T7
1 x 9-5 Exhaust Flex Pipe Stainless
1 x BSR 9-5 3.0T V6 200Hp
1 x 9-5 Open Air Prefilter
1 x Front Camber Adjustment Bolts
1 x Oil Pressure Switch
1 x Headlight Bulb H7 Longer Life
1 x Floormats BSR 9-5
1 x BSR 9-5 260Hp 2006-
1 x Air Filter 06 version (All 9-5)
1 x 9-5 Shift Knobs Leather
1 x Rear Camber Shims Kit 6pcs
3 x Turbo Bypass Valve
2 x Downpipe Hardware Kit
1 x Filter 9-5 Cabin Air
1 x Bulb Switch Light
1 x Coolant Bypass Valve 9-5
2 x Crush Sleeve F35 F25
1 x Cigarette Lighter
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-5 Textile Mats 98-07
2 x Flywheel Twin Disk 7.25in B2xx
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Slave Cyl
1 x Replacement Filter for Open air 9-3 T7
1 x Aero Clutch Kit 9-5
1 x Fog light Replacement Panels 99-01
1 x Remote Button NG900
2 x Shift Rod Bushings
1 x Downpipe 2.8T FWD (2wd)
2 x v6oilcoolplate
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Transmission Nut F35 F25
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Exhaust manifold Stud Kit
1 x Rear spring perches Adjustable NG900/9-3
1 x Oil Cap 9-3SS "Ghost"
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x v6 header flange
1 x 9000 Shifter Bushing Repair Kit
1 x 20th Viggen logo Shifter Top
1 x Open Air Intake 9000 93-98
1 x Machined Control Arm Kit
1 x 9000 Intercooler ETS
1 x Limit Strap Coilover Add On Kit
$21,257.47
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail