$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Sport Transmission Mount 9-3/900 (Automatic)
3 x Rear Camber Shims Kit 6pcs
1 x Universal / Special Request
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x Rear Engine Mount 4cyl
1 x 9-3 /NG900 Grille
1 x 9-3 ng900 radio wires
2 x Flex Pipe 900 94-98 9-3 99-02
3 x ATF Saab 3309 (Automatic 02->)
1 x 4340 Connecting Rods B204 B235
1 x Crank Vent Kit #6 T7 4cyl
1 x IAT Weld Bung T5/Bosch
1 x Replacement Filter for Open air 9-3 T7
1 x Genuine Saab 4cyl Oil Filters
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Flywheel Twin Disk 7.25in B2xx
2 x Adaptor Harness Handsfree 01-
1 x 9-3/NG900 Shift Knobs Leather
1 x Midpipe 2.8T FWD (2wd)
1 x JE Piston Rings 90.0mm 235/205
1 x Midpipe 2.8T XWD (4wd)
2 x Slave Cyl
1 x Direct Ignition T5 RED
1 x Shifter Mount Kit Cobalt/ HHR
2 x Basic Subframe Brace
2 x Alu Hybrid Flywheel For NG900/9-3
1 x Map/MAT sensor weld bung
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
3 x Rear spring perches Adjustable NG900/9-3
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x 9-5 Aero Sill Protection
1 x Fog light 9-3 Right 99-00
1 x Mass Airflow Meter T7
2 x Exhaust Clamp Kit
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Floormats BSR 9-3 99-02 900 94-98
2 x Oil Filter Re-locator
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Clear Little Fender Blinkers Factory Saab
2 x BBS Center Cap for 9-2x RK small caps
1 x "Griffin" Valve stem caps
1 x Intake Flange B2x4 T5
1 x Direct Ignition T7 Black
2 x Crush Sleeve F35 F25
1 x Throttle Bend for T5 94-99
3 x Shifter Alignment Pins (Set 2)
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Fuel Pressure Regulator 4.0 bar
1 x Short Shifter HHR Cobalt F35 F40
2 x Oil Cooler Adaptor B2X5
2 x c900 Performance Brake lines
1 x Throttle Body T7
1 x Coreganizer
1 x Griffin logo Shifter Top
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Aero Clutch Kit 9-5
2 x 9000 High Performance Brake Line Kit '95-'98
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
3 x 9-3 / 900 Uprated Front ARB Bushings
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
3 x Shift Rod Bushings
1 x Head Stud Kit all 4cyl
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x 9-5 High Performance Brake Line Kit
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Custom Brake Lines RR 300mm Kit
1 x Limit Strap Coilover Add On Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Weld Bungs -Taper- Race Only
1 x 9-5 Textile Mats 98-07
1 x Cigarette Lighter
1 x 9-5 Shift Knobs Leather
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Floormats BSR 9-5
1 x PPC 3 Volvo Diagnostic System
1 x Bulb Switch Light
2 x K&N Filter Service Kit
1 x 9000 Intercooler ETS
1 x Exhaust manifold Stud Kit
1 x 9000 Shifter Bushing Repair Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Injectors Green Giant 42lb (set 4)
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x MTF0063 Manual Gear oil
$20,106.01
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail