$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x K&N Filter Service Kit
4 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
4 x Flex Pipe 900 94-98 9-3 99-02
3 x IAT Weld Bung T5/Bosch
3 x Aluminum Flywheel For NG900/9-3
3 x c900 Performance Brake lines
2 x Intake Flange B2x4 T5
2 x Moog Ball Joint
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
3 x Replacement Flywheel Insert NG900/9-3
5 x Exhaust Clamp Kit
2 x Injectors Siemens 60lb 630cc (set 4)
3 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
3 x PPC - Upgrade from stage 1 to stage 3
3 x Shifter Alignment Pins (Set 2)
4 x Adaptor Harness Handsfree 01-
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Shifter Mount Kit Cobalt/ HHR
1 x 4340 Connecting Rods B204 B235
1 x Balance Shaft Tensioner Delete
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
3 x Headbolts (New Style)
1 x Rod Bearings only Pauter Rods
1 x Oil Filter Re-locator
1 x Head Stud Kit all 4cyl
1 x Steering Coupler 9-3 99-02
2 x Steering Rod Bushings NG900/93
3 x Rear Camber Shims Kit 6pcs
2 x 9-3 / 900 Uprated Front ARB Bushings
4 x Limit Strap Coilover Add On Kit
1 x Machined Control Arm Kit
1 x Replacement Filter for Open air 9-3 T7
1 x Downpipe Hardware Kit
1 x Fuel Line Clip
1 x Crush Sleeve F35 F25
1 x Direct Ignition T7 Black
1 x Saab black Keychain
1 x Viggen Titanium KeyChain
1 x 9000 Shifter Bushing Repair Kit
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x 9-5 Wheel 10-Spoke 16in.
2 x Viggen Clutch Kit 99-02
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Metal Steering Wheel Buttons
1 x Floormats BSR 9-3SS/SC
2 x Cat back for Viggen 2.5in
2 x Weld Bungs -Taper- Race Only
1 x Head Bolt Washers
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Brake Vac pump seals
1 x Rivetnuts Pair (2pcs)
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x B207 Upper Radiator Coolant T
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Map/MAT sensor weld bung
1 x Fuel Pressure Regulator 4.0 bar
1 x V6 Tank Float - SparePart
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Optical Cable Connector (Onstar Delete)
1 x Shifter Mount Kit 93ss
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x ShortShift Kit 93ss
1 x Front Camber Adjustment Bolts
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Replacement V6 Coolant Cap
1 x Universal / Special Request
1 x Sparkplugs 9-3SS
1 x Clear Little Fender Blinkers Factory Saab
1 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x Flywheel Twin Disk 7.25in B2xx
1 x Exhaust manifold Stud Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Shift Rod Bushings
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Slave Cyl
2 x 9-3 ng900 radio wires
2 x 20th Viggen logo Shifter Top
2 x Floormats BSR 9-3 99-02 900 94-98
2 x PPC 3 Volvo Diagnostic System
1 x Coreganizer
1 x Rear Engine Mount 4cyl
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x T7 Head Plug NGK
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Aero Clutch Kit 9-5
1 x Turbo Conversion Pipe 900 9-3 T5
2 x Viggen Fog Air Intake
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cooler Adaptor B2X5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x T7 Injector Spacer Kit
1 x Turbo Bypass Valve
1 x Mass Airflow Meter T7
1 x Crank Vent Kit #6 T7 4cyl
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Replacement Hardware Pack 6-Point
1 x Genuine Saab 4cyl Oil Filters
$27,751.62
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail