$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Injectors Siemens 80lb 875cc (set 4)
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
3 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x 3 Point Hardware
3 x Moog Ball Joint
3 x Shifter Mount Kit Cobalt/ HHR
2 x K&N Filter Service Kit
1 x Flex Pipe 900 94-98 9-3 99-02
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Flywheel Twin Disk 7.25in B2xx
2 x Saab black Keychain
2 x Exhaust manifold Stud Kit
1 x c900 Performance Brake lines
2 x Rivetnuts Pair (2pcs)
3 x Oil Cap GM "HHR"
3 x Shift Rod Bushings
1 x Slave Cyl
2 x Aero Clutch Kit 9-5
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Spec Light Flywheel For 9-5 4cyl 99-09
2 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Rear spring perches Adjustable NG900/9-3
2 x Machined Control Arm Kit
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Steering Coupler 9-3 99-02
1 x Steering Rod Bushings NG900/93
1 x Limit Strap Coilover Add On Kit
2 x 9-3 / 900 Uprated Front ARB Bushings
2 x Rear Camber Shims Kit 6pcs
1 x Basic Subframe Brace
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Downpipe Hardware Kit
2 x Antenna Plug NG900/9-3 hatchback
1 x 9-5 Exhaust Flex Pipe Stainless
2 x Mass Airflow Meter T7
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Coolant Bypass Valve 9-5
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-3 /NG900 Grille
3 x 20th Viggen logo Shifter Top
1 x Filter 9-5 Cabin Air
2 x 9-5 Blend Flap Limit Lever 99-04
2 x Headbolts (New Style)
2 x Genuine Saab 4cyl Oil Filters
1 x 9-5 Open Air Prefilter
1 x 9-5 Rear Brake rotor See Description
2 x BSR 9-5 2010-2011 V6 300Hp
1 x Direct Ignition T7 Black
1 x 9-5 Textile Mats 98-07
2 x 9-5 Aero Sill Protection
1 x Cabin Vent Fan
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Air Filter 06 version (All 9-5)
2 x 9-5 Shift Knobs Leather
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Headlight Bulb H7 Longer Life
2 x "Griffin" Valve stem caps
1 x Crank Vent Kit #6 T7 4cyl
3 x Crush Sleeve F35 F25
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x 9-3/NG900 Shift Knobs Leather
1 x Oil Pressure Switch
2 x Fuel Line Clip
1 x 9-3 ng900 Hood Protection Strip
1 x Head Stud Kit all 4cyl
2 x SCNA Christmas Calendar
1 x BBS Center Cap for 9-2x RK small caps
2 x Weld Bungs -Taper- Race Only
3 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x T5 3.0 Bar Map Sensor Adaptor
3 x PPC - Upgrade from stage 1 to stage 3
2 x Injectors Green Giant 42lb (set 4)
2 x Fuel Pressure Regulator 4.0 bar
2 x Universal / Special Request
2 x IAT Weld Bung T5/Bosch
3 x Head Bolt Washers
2 x Map/MAT sensor weld bung
1 x Sparkplugs 9-3SS
1 x V6 Tank Float - SparePart
1 x Hood Emblem 9-3 SS/sc 03- All
2 x Brake Vac pump seals
3 x Clear Little Fender Blinkers Factory Saab
1 x Rear Pedestal Spoiler 9-3 SS
1 x Optical Cable Connector (Onstar Delete)
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Replacement V6 Coolant Cap
1 x Hood Emblem 9-5 All
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Headlight Connector Repair Kit 9-3SS 9-5
2 x B207 Upper Radiator Coolant T
1 x Fog light Replacement Panels 99-01
1 x B207 Coolant Cap
1 x Rear Engine Mount 4cyl
1 x Con Rods V6 2.8L 155.8mm
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x Direct Ignition T5 RED
1 x BSR Optiflow Intake 4cyl
2 x T7 Injector Spacer Kit
1 x 9000 Shifter Bushing Repair Kit
1 x Shifter Alignment Pins (Set 2)
1 x ATF Saab 3309 (Automatic 02->)
3 x Intake Flange B2x4 T5
3 x Griffin logo Shifter Top
1 x Floormats BSR 9-3SS/SC
2 x Coreganizer
1 x Viggen Titanium KeyChain
2 x MTF0063 Manual Gear oil
2 x Adaptor Harness Handsfree 01-
1 x Metal Steering Wheel Buttons
2 x Oil Cooler Adaptor B2X5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Throttle Bend for T5 94-99
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cap 9-3SS "Ghost"
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Floormats BSR 9-3 99-02 900 94-98
1 x AEM Wideband Gauge Kit
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Viggen Fog Air Intake
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Alu Hybrid Flywheel For NG900/9-3
1 x 9-3 ng900 radio wires
1 x 9-3 Rear Ashtray
1 x v6 header flange
1 x Oil Filter Re-locator
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x v6oilcoolplate
1 x ShortShift Kit 93ss
1 x 4340 Connecting Rods B204 B235
1 x Fog light 9-3 left 99-00
1 x Exhaust Clamp Kit
1 x Rod Bearings only Pauter Rods
2 x Forge Bypass Valve Cobalt/HHR TC
1 x BSR 9-5 260Hp 2006-
1 x Viggen Front Brake Disk Pair 308mm
$28,282.59
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail