$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Viggen Fog Air Intake
1 x Turbo Conversion Pipe 900 9-3 T5
4 x Rear Camber Shims Kit 6pcs
3 x PPC 3 Volvo Diagnostic System
2 x ARP Ring Gear Bolts F25/F35
2 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Clear Little Fender Blinkers Factory Saab
1 x BBS Center Cap for 9-2x RK small caps
1 x "Griffin" Valve stem caps
1 x Throttle Bend for T5 94-99
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Fog light 9-3 left 99-00
2 x Rear spring perches Adjustable NG900/9-3
2 x Basic Subframe Brace
3 x Steering Coupler 9-3 99-02
1 x Steering Rod Bushings NG900/93
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x 9-5 Wheel 5-Spoke Twin 17in
2 x ARP Exhaust Manifold Stud kit Stainless
2 x Head Stud Kit all 4cyl
2 x 9-3 ng900 Hood Protection Strip
1 x Fog light Replacement Panels
2 x Slave Cyl
2 x SCNA Christmas Calendar
1 x Drop in Sport Filter 9-5
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x 9-5 Rear Brake rotor See Description
1 x Upgrade Valve Springs T5 Cars
1 x Aero Clutch Kit 9-5
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x BSR 9-5 260Hp 2006-
1 x 9-3 SS Akebono Rear Pads
1 x 9-5 Textile Mats 98-07
2 x Rivetnuts Pair (2pcs)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Coreganizer
1 x Short Shifter HHR Cobalt F35 F40
2 x Fuel Pressure Regulator 4.0 bar
3 x Machined Control Arm Kit
1 x ATF Saab 3309 (Automatic 02->)
2 x Moog Ball Joint
1 x Adaptor Harness Handsfree 01-
2 x 9-3/NG900 Shift Knobs Leather
3 x Downpipe Hardware Kit
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-3 ng900 radio wires
1 x Shifter Mount Kit Cobalt/ HHR
1 x BSR 9-5 3.0T V6 200Hp
2 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-3 /NG900 Grille
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Griffin logo Shifter Top
2 x Replacement V6 Coolant Cap
1 x Antenna Plug NG900/9-3 hatchback
2 x AEM Wideband Gauge Kit
2 x 9-5 Open Air Prefilter
1 x K&N Filter Service Kit
2 x 9-5 Aero Sill Protection
2 x Rear Engine Mount 4cyl
1 x 4340 Connecting Rods B204 B235
1 x Replacement Filter for Open air 9-3 T7
1 x IAT Weld Bung T5/Bosch
2 x Crank Vent Kit #6 T7 4cyl
1 x Oil Filter Re-locator
3 x Headbolts (New Style)
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x Flex Pipe 900 94-98 9-3 99-02
2 x Genuine Saab 4cyl Oil Filters
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Remote Button NG900
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Replacement Hardware Pack 6-Point
1 x JE Piston Rings 90.0mm 235/205
1 x Intake Flange B2x4 T5
2 x Crush Sleeve F35 F25
2 x Mass Airflow Meter T7
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
2 x PPC - Upgrade from stage 1 to stage 3
1 x Direct Ignition T5 RED
2 x T7 Head Plug NGK
1 x Map/MAT sensor weld bung
1 x Cat back for Viggen 2.5in
1 x Head Bolt Washers
2 x Direct Ignition T7 Black
1 x Troll Head Plug
1 x Injectors Green Giant 42lb (set 4)
1 x Balance Shaft Tensioner Delete
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Universal / Special Request
1 x Hood Emblem 9-5 All
1 x Exhaust manifold Stud Kit
1 x 9000 Shifter Bushing Repair Kit
1 x B207 Coolant Cap
1 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Exhaust Clamp Kit
1 x Rod Bearings only Pauter Rods
1 x Con Rods V6 2.8L 155.8mm
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Fog light Replacement Panels 99-01
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Injectors Siemens 60lb 630cc (set 4)
1 x 9-5 High Performance Brake Line Kit
1 x Shifter Top Ghost Logo
1 x Filter 9-5 Cabin Air
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x c900 Performance Brake lines
1 x Oil Pressure Switch
1 x Quaife Differential 9-5 and Viggen (F35)
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Flywheel Twin Disk 7.25in B2xx
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Fuel Line Clip
1 x Replacement Flywheel Insert NG900/9-3
1 x Coolant Bypass Valve 9-5
1 x Transmission Nut F35 F25
1 x Aluminum Flywheel For NG900/9-3
1 x Headlight Bulb H7 Longer Life
1 x Custom Brake Lines RR 300mm Kit
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x Fog light 9-3 Right 99-00
1 x Shifter Mount Kit 93ss
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x ShortShift Kit 93ss
1 x BSR Optiflow Intake 4cyl w SAI
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Front Camber Adjustment Bolts
$28,671.25
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail