$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Injectors Siemens 60lb 630cc (set 4)
2 x Viggen Clutch Kit 99-02
4 x Intake Flange B2x4 T5
7 x PPC - Upgrade from stage 1 to stage 3
3 x Fog light 9-5 Aero 04-05, 06-08 All Left
4 x IAT Weld Bung T5/Bosch
3 x Short Shifter HHR Cobalt F35 F40
3 x Map/MAT sensor weld bung
2 x Shifter Top Ghost Logo
2 x AEM Wideband Gauge Kit
3 x ATF Saab 3309 (Automatic 02->)
1 x 9-3 Rear Ashtray
3 x Rear Engine Mount 4cyl
2 x K&N Filter Service Kit
2 x Adaptor Harness Handsfree 01-
1 x Coreganizer
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Floormats BSR 9-3 99-02 900 94-98
2 x Transmission Nut F35 F25
1 x 9-3 99-02,03 CV Antenna Adaptor
4 x Oil Cap 9-3SS V6 "Griffin"
1 x 9-3/NG900 Shift Knobs Leather
1 x Aluminum Flywheel For NG900/9-3
3 x Oil Cap 9-3SS V6 "Ghost"
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
4 x Shift Rod Bushings
2 x Flywheel Twin Disk 7.25in B2xx
3 x Griffin logo Shifter Top
2 x 9-3 ng900 radio wires
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Slave Cyl
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x BSR Optiflow Intake 4cyl w SAI
1 x Cat back for Viggen 2.5in
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x B207 Coolant Cap
1 x BSR Optiflow Intake V6 2.8t
1 x BSR Optiflow Replacement Filter V6 2.8
5 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Midpipe 2.8T FWD (2wd)
1 x BSR Optiflow Intake 4cyl
1 x Downpipe 2.8T FWD (2wd)
1 x Downpipe 2.8T XWD (4wd)
2 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Midpipe 2.8T XWD (4wd)
2 x Flex Pipe 900 94-98 9-3 99-02
4 x ARP Exhaust Manifold Stud kit Stainless
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Exhaust Clamp Kit
3 x Clear Little Fender Blinkers Factory Saab
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Con Rods V6 2.8L 155.8mm
1 x Injectors 175hp Stg3 (Set4)
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
2 x Rivetnuts Pair (2pcs)
1 x BSR 9-5 260Hp 2006-
3 x Head Bolt Washers
2 x Fuel Pressure Regulator 4.0 bar
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x v6 header flange
3 x Weld Bungs -Taper- Race Only
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
2 x Oil Filter Re-locator
2 x Injectors Siemens 80lb 875cc (set 4)
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Brake Vac pump seals
1 x v6oilcoolplate
2 x Moog Ball Joint
3 x Injectors Green Giant 42lb (set 4)
3 x Saab black Keychain
1 x BSR 9-5 3.0T V6 200Hp
3 x Forge Bypass Valve Cobalt/HHR TC
2 x MTF0063 Manual Gear oil
1 x Direct Ignition T7 Black
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Steering Rod Bushings NG900/93
1 x Replacement Hardware Pack 6-Point
1 x Mass Airflow Meter T7
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Fuel Line Clip
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Genuine Saab 4cyl Oil Filters
1 x Limit Strap Coilover Add On Kit
1 x Basic Subframe Brace
2 x Replacement Filter for Open air 9-3 T7
1 x Remote Button NG900
2 x Crush Sleeve F35 F25
1 x Crank Vent Kit #6 T7 4cyl
1 x Downpipe Hardware Kit
1 x Direct Ignition T5 RED
2 x Steering Coupler 9-3 99-02
1 x Rear spring perches Adjustable NG900/9-3
2 x Rear Camber Shims Kit 6pcs
2 x Head Stud Kit all 4cyl
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x 9-5 Textile Mats 98-07
2 x Drop in Sport Filter 9-5
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Floormats BSR 9-5
1 x Cigarette Lighter
1 x Bulb Switch Light
1 x 9-5 Shift Knobs Leather
2 x 9-5 Intercooler ETS
2 x T7 Injector Spacer Kit
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Viggen Fog Air Intake
2 x Mat Set Black Rubber 9-5 10-
1 x Floormats BSR 9-3SS/SC
4 x Oil Cap GM "HHR"
1 x Replacement V6 Coolant Cap
2 x B207 Upper Radiator Coolant T
1 x Ignition Coil 9-3SS 2.8t and 2.8T
3 x SCNA Christmas Calendar
1 x 9-3 /NG900 Grille
1 x Fog light Replacement Panels
2 x Mat Set Textile Shark Grey 9-5 10-
1 x V6 Tank Float - SparePart
1 x Mat Set Textile Parchment 9-5 10-
1 x Rear Pedestal Spoiler 9-3 SS
2 x Storage Tray / Ashtray Kit 9-5 10-
2 x Shifter Mount Kit Cobalt/ HHR
1 x Open Air Intake 9000 93-98
2 x Front Camber Adjustment Bolts
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 9000 High Performance Brake Line Kit '95-'98
1 x 9000 Shifter Bushing Repair Kit
1 x 9000 Intercooler ETS
4 x 9-5 Aero Sill Protection
1 x Shifter Mount Kit 93ss
2 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Fog light Replacement Panels 99-01
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Oil Cooler Adaptor B2X5
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x ShortShift Kit 93ss
1 x Machined Control Arm Kit
1 x 20th Viggen logo Shifter Top
1 x Oil Cap 9-3SS "Ghost"
2 x Hood Emblem 9-5 All
1 x Alu Hybrid Flywheel For NG900/9-3
1 x 9-5 Rear Brake rotor See Description
1 x Shifter Alignment Pins (Set 2)
1 x 9-3 ng900 Hood Protection Strip
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x Mat Set Textile Jet Black 9-5 10-
1 x JE Piston Rings 90.0mm 235/205
1 x Balance Shaft Tensioner Delete
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x c900 Performance Brake lines
1 x Headbolts (New Style)
$38,120.35
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail