$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x 9-3 ng900 Hood Protection Strip
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Fog light 9-3 Right 99-00
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Transmission Nut F35 F25
1 x Shifter Top Ghost Logo
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Clear Little Fender Blinkers Factory Saab
1 x Flywheel Twin Disk 7.25in B2xx
1 x Cat back for Viggen 2.5in
1 x ARP Ring Gear Bolts F25/F35
1 x Replacement Flywheel Insert NG900/9-3
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Antenna Plug NG900/9-3 hatchback
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Fog light Replacement Panels
1 x Rear Engine Mount 4cyl
1 x Exhaust Clamp Kit
1 x Shift Rod Bushings
1 x Aluminum Flywheel For NG900/9-3
1 x Exhaust manifold Stud Kit
1 x Slave Cyl
1 x Fog light 9-3 left 99-00
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x 9-3 /NG900 Grille
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Replacement V6 Coolant Cap
1 x Limit Strap Coilover Add On Kit
1 x SCNA Christmas Calendar
1 x 9000 Shifter Bushing Repair Kit
1 x Con Rods V6 2.8L 155.8mm
1 x Troll Head Plug
1 x T7 Head Plug NGK
1 x B207 Coolant Cap
1 x MTF0063 Manual Gear oil
1 x Shifter Alignment Pins (Set 2)
1 x K&N Filter Service Kit
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x ATF Saab 3309 (Automatic 02->)
1 x PPC 3 Volvo Diagnostic System
1 x Balance Shaft Tensioner Delete
1 x Head Stud Kit all 4cyl
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x T7 Injector Spacer Kit
1 x Viggen Fog Air Intake
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Oil Cooler Adaptor B2X5
1 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Rear spring perches Adjustable NG900/9-3
1 x Head Bolt Washers
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x PPC - Upgrade from stage 1 to stage 3
1 x c900 Performance Brake lines
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Basic Subframe Brace
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
$10,018.64
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail