$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Short Shifter HHR Cobalt F35 F40
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Shifter Mount Kit Cobalt/ HHR
1 x Oil Cap GM "HHR"
1 x Steering Coupler 9-3 99-02
3 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x PPC 3 Volvo Diagnostic System
1 x Direct Ignition T5 RED
2 x Mass Airflow Meter T7
2 x Downpipe Hardware Kit
2 x Fuel Line Clip
3 x Exhaust Clamp Kit
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x SCNA Christmas Calendar
1 x Con Rods V6 2.8L 155.8mm
1 x Slave Cyl
1 x Shifter Top Ghost Logo
2 x Clear Little Fender Blinkers Factory Saab
2 x Replacement Flywheel Insert NG900/9-3
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x c900 Performance Brake lines
2 x Transmission Nut F35 F25
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Rear Engine Mount 4cyl
1 x ARP Ring Gear Bolts F25/F35
1 x Shift Rod Bushings
1 x 9-3 Rear Ashtray
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-3/NG900 Shift Knobs Leather
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 ng900 radio wires
1 x Adaptor Harness Handsfree 01-
1 x Griffin logo Shifter Top
1 x 20th Viggen logo Shifter Top
1 x Flex Pipe 900 94-98 9-3 99-02
2 x Oil Cooler Adaptor B2X5
1 x Head Bolt Washers
1 x Fog light Replacement Panels
1 x 9-3 /NG900 Grille
1 x BSR 9-5 3.0T V6 200Hp
1 x Spec Light Flywheel For 9-5 4cyl 99-09
2 x PPC - Upgrade from stage 1 to stage 3
1 x Aero Clutch Kit 9-5
2 x 9-5 Aero Sill Protection
1 x MTF0063 Manual Gear oil
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Air Filter 06 version (All 9-5)
1 x Limit Strap Coilover Add On Kit
2 x Rear Camber Shims Kit 6pcs
1 x Mat Set Textile Parchment 9-5 10-
1 x Steering Rod Bushings NG900/93
2 x Crush Sleeve F35 F25
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Headlight Bulb H7 Longer Life
1 x BBS Center Cap for 9-2x RK small caps
1 x Brake Vac pump seals
1 x Oil Filter Re-locator
1 x 9000 Shifter Bushing Repair Kit
1 x v6oilcoolplate
1 x 3 Point Hardware
1 x Intake Flange B2x4 T5
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Midpipe 2.8T FWD (2wd)
1 x Floormats BSR 9-3SS/SC
1 x Throttle Bend for T5 94-99
1 x Upgrade Valve Springs T5 Cars
1 x Troll Head Plug
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Exhaust manifold Stud Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Green Giant 42lb (set 4)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Moog Ball Joint
1 x Universal / Special Request
1 x Injectors Siemens 60lb 630cc (set 4)
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-5 Wheel 10-Spoke 16in.
$13,703.05
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail