$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x B207 Coolant Cap
3 x Shifter Alignment Pins (Set 2)
2 x K&N Filter Service Kit
3 x ATF Saab 3309 (Automatic 02->)
2 x Replacement V6 Coolant Cap
1 x Viggen Titanium KeyChain
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Injectors Siemens 60lb 630cc (set 4)
2 x Intake Flange B2x4 T5
1 x IAT Weld Bung T5/Bosch
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Injectors Green Giant 42lb (set 4)
1 x AEM Wideband Gauge Kit
1 x c900 Performance Brake lines
1 x Universal / Special Request
1 x Moog Ball Joint
1 x Fuel Pressure Regulator 4.0 bar
2 x Clear Little Fender Blinkers Factory Saab
1 x Head Bolt Washers
1 x Map/MAT sensor weld bung
1 x Rivetnuts Pair (2pcs)
1 x PPC - Upgrade from stage 1 to stage 3
2 x Troll Head Plug
1 x Balance Shaft Tensioner Delete
1 x Rod Bearings only Pauter Rods
2 x T7 Head Plug NGK
1 x B207 Upper Radiator Coolant T
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
1 x 9000 Shifter Bushing Repair Kit
1 x Con Rods V6 2.8L 155.8mm
1 x 9-3 /NG900 Grille
1 x Fog light 9-3 left 99-00
1 x Replacement Hardware Pack 6-Point
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Replacement Filter for Open air 9-3 T7
1 x Mass Airflow Meter T7
1 x Remote Button NG900
1 x Downpipe Hardware Kit
1 x v6 header flange
1 x Crank Vent Kit #6 T7 4cyl
1 x 9-3 Rear Ashtray
1 x Adaptor Harness Handsfree 01-
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Machined Control Arm Kit
1 x Rear Camber Shims Kit 6pcs
1 x Viggen Fog Air Intake
1 x Replacement Flywheel Insert NG900/9-3
1 x Exhaust manifold Stud Kit
1 x ARP Ring Gear Bolts F25/F35
1 x Steering Coupler 9-3 99-02
1 x Exhaust Clamp Kit
1 x Basic Subframe Brace
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Slave Cyl
1 x Limit Strap Coilover Add On Kit
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Flywheel Twin Disk 7.25in B2xx
1 x Transmission Nut F35 F25
1 x 9-5 Rear Brake rotor See Description
1 x Mat Set Textile Shark Grey 9-5 10-
1 x Mat Set Textile Jet Black 9-5 10-
1 x Mat Set Black Rubber 9-5 10-
$8,957.57
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail