$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Con Rods V6 2.8L 155.8mm
1 x Replacement V6 Coolant Cap
2 x Limit Strap Coilover Add On Kit
1 x SCNA Christmas Calendar
1 x Viggen Titanium KeyChain
1 x Saab black Keychain
2 x Shifter Mount Kit Cobalt/ HHR
1 x c900 Performance Brake lines
2 x MTF0063 Manual Gear oil
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x Crank Vent Kit #6 T7 4cyl
1 x Remote Button NG900
2 x PPC - Upgrade from stage 1 to stage 3
2 x Machined Control Arm Kit
2 x Rear Engine Mount 4cyl
1 x Shift Rod Bushings
2 x Steering Coupler 9-3 99-02
2 x Rear Camber Shims Kit 6pcs
1 x Downpipe Hardware Kit
3 x Exhaust Clamp Kit
2 x Replacement Hardware Pack 6-Point
1 x Steering Rod Bushings NG900/93
1 x Rear spring perches Adjustable NG900/9-3
2 x 9-3 / 900 Uprated Front ARB Bushings
2 x Genuine Saab 4cyl Oil Filters
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Replacement Filter for Open air 9-3 T7
3 x Flex Pipe 900 94-98 9-3 99-02
1 x Direct Ignition T5 RED
4 x Crush Sleeve F35 F25
2 x PPC 3 Volvo Diagnostic System
2 x Basic Subframe Brace
1 x Direct Ignition T7 Black
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Viggen Fog Air Intake
1 x Turbo Conversion Pipe 900 9-3 T5
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x T7 Injector Spacer Kit
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Mat Set Textile Jet Black 9-5 10-
2 x Mat Set Textile Shark Grey 9-5 10-
1 x Throttle Bend for T5 94-99
2 x Oil Cooler Adaptor B2X5
1 x Oil Cap 9-3SS V6 "Griffin"
3 x Exhaust manifold Stud Kit
1 x Mat Set Textile Parchment 9-5 10-
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Mat Set Black Rubber 9-5 10-
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x 9-5 Aero Sill Protection
2 x Storage Tray / Ashtray Kit 9-5 10-
2 x Cat back for Viggen 2.5in
2 x ARP Exhaust Manifold Stud kit Stainless
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Oil Filter Re-locator
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
1 x Balance Shaft Tensioner Delete
1 x Clear Little Fender Blinkers Factory Saab
1 x 9-3 /NG900 Grille
1 x 4340 Connecting Rods B204 B235
1 x Fog light 9-3 left 99-00
2 x Headbolts (New Style)
1 x 9-3 ng900 Hood Protection Strip
1 x Cigarette Lighter
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Moog Ball Joint
1 x Front Camber Adjustment Bolts
1 x Floormats BSR 9-5
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Coolant Bypass Valve 9-5
1 x 9000 Shifter Bushing Repair Kit
1 x BSR Optiflow Intake 4cyl
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Drop in Sport Filter 9-5
1 x Turbo Bypass Valve
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x BSR 9-5 2010-2011 V6 300Hp
1 x B207 Coolant Cap
1 x Aero Clutch Kit 9-5
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Bulb Switch Light
$17,522.30
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail