$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Genuine Saab 4cyl Oil Filters
3 x Throttle Bend for T5 94-99
7 x 20th Viggen logo Shifter Top
8 x Shift Rod Bushings
6 x Flywheel Twin Disk 7.25in B2xx
4 x Rod Bearings only Pauter Rods
6 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Shifter Top Ghost Logo
2 x Short Shifter HHR Cobalt F35 F40
4 x Rear spring perches Adjustable NG900/9-3
1 x 9-3 /NG900 Grille
4 x c900 Performance Brake lines
3 x Direct Ignition T7 Black
3 x 9-3 ng900 radio wires
3 x Saab black Keychain
3 x Shifter Mount Kit Cobalt/ HHR
3 x Replacement Filter for Open air 9-3 T7
8 x 9-3 / 900 Uprated Front ARB Bushings
1 x Replacement Hardware Pack 6-Point
2 x Remote Button NG900
8 x Exhaust manifold Stud Kit
3 x IAT Weld Bung T5/Bosch
4 x JE Piston Rings 90.0mm 235/205
3 x 9-3/NG900 Shift Knobs Leather
5 x T7 3.5 Bar Fuel Pressure Regulator
3 x 9-3 99-02,03 CV Antenna Adaptor
5 x Balance Shaft Tensioner Delete
4 x Downpipe Hardware Kit
5 x Headbolts (New Style)
4 x T7 Injector Spacer Kit
5 x MTF0063 Manual Gear oil
2 x Adaptor Harness Handsfree 01-
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x Quaife Differential 9-5 and Viggen (F35)
3 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
4 x Aluminum Flywheel For NG900/9-3
2 x Cat back for Viggen 2.5in
3 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Cat Back Exh for 9000 CS, CSE AERO
3 x Injectors Green Giant 42lb (set 4)
4 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
3 x Griffin logo Shifter Top
2 x K&N Filter Service Kit
2 x Open Air Intake 9000 93-98
3 x Head Bolt Washers
3 x Downpipe 2.8T XWD (4wd)
2 x Weld Bungs -Taper- Race Only
3 x Torque Mount Insert V6 Manual (XWD and FWD)
3 x B207 Coolant Cap
1 x SCNA Christmas Calendar
2 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
2 x v6oilcoolplate
3 x Basic Subframe Brace
1 x Turbo to Downpipe Flange B207
4 x 9-5 Exhaust Flex Pipe Stainless
2 x Brembo Brake Kit 315mm 9-5 02-->
1 x v6 2.8t SAI Delete Kit
1 x v6 header flange
5 x Viggen Fog Air Intake
1 x "Griffin" Valve stem caps
3 x Front Camber Adjustment Bolts
5 x Rear Camber Shims Kit 6pcs
3 x Limit Strap Coilover Add On Kit
4 x Oil Cap 9-3SS V6 "Griffin"
1 x Storage Tray / Ashtray Kit 9-5 10-
3 x 9-3 / 900 Uprated Suspension Bushings Inner
4 x Oil Cap 9-3SS V6 "Ghost"
1 x Mat Set Textile Jet Black 9-5 10-
1 x Mat Set Black Rubber 9-5 10-
1 x Mat Set Textile Shark Grey 9-5 10-
4 x Steering Coupler 9-3 99-02
1 x Mat Set Textile Parchment 9-5 10-
2 x Clear Little Fender Blinkers Factory Saab
4 x Rear Engine Mount 4cyl
5 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x ShortShift Kit 93ss
1 x BSR 9-5 2010-2011 V6 300Hp
3 x Turbo Conversion Pipe 900 9-3 T5
2 x Coreganizer
1 x 9-5 Shift Knobs Leather
4 x Oil Cooler Adaptor B2X5
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x 9-5 Wheel 5-Spoke Twin 17in
1 x Antenna Plug NG900/9-3 hatchback
2 x Air Filter 06 version (All 9-5)
3 x ATF Saab 3309 (Automatic 02->)
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
3 x Moog Ball Joint
2 x BSR Optiflow Intake 4cyl
1 x Oil Pressure Switch
2 x BSR Optiflow Intake V6 2.8t
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Viggen Clutch Kit 99-02
1 x Headlight Bulb H7 Longer Life
3 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Cabin Vent Fan
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
2 x Mass Airflow Meter T7
2 x 9-5 Open Air Prefilter
1 x Coolant Bypass Valve 9-5
2 x BSR Optiflow Intake 4cyl w SAI
3 x Replacement Flywheel Insert NG900/9-3
2 x Filter 9-5 Cabin Air
1 x Midpipe 2.8T XWD (4wd)
2 x Slave Cyl
2 x Fuel Line Clip
2 x Midpipe 2.8T FWD (2wd)
1 x Injectors 175hp Stg3 (Set4)
2 x Con Rods V6 2.8L 155.8mm
2 x Oil Cap 9-3SS "Ghost"
3 x Crank Vent Kit #6 T7 4cyl
5 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Turbo Bypass Valve
3 x T5 3.0 Bar Map Sensor Adaptor
1 x Universal / Special Request
5 x T7 Head Plug NGK
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Oil Filter Re-locator
3 x ARP Exhaust Manifold Stud kit Stainless
3 x Head Stud Kit all 4cyl
1 x 9-5 Intercooler ETS
3 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x PPC - Upgrade from stage 1 to stage 3
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
5 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Intake Flange B2x4 T5
2 x 9-5 Aero Sill Protection
2 x Fog light Replacement Panels 99-01
2 x Machined Control Arm Kit
3 x Map/MAT sensor weld bung
2 x Upgrade Valve Springs T5 Cars
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
2 x Fog light Replacement Panels
1 x 9-5 High Performance Brake Line Kit
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
2 x Exhaust Clamp Kit
1 x 4340 Connecting Rods B204 B235
1 x ARP Ring Gear Bolts F25/F35
1 x Replacement V6 Coolant Cap
1 x 9-3 SS Akebono Rear Pads
2 x AEM Wideband Gauge Kit
1 x Fuel Pressure Regulator 4.0 bar
1 x Fog light 9-3 left 99-00
1 x Rivetnuts Pair (2pcs)
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Ignition Coil 9-3SS 2.8t and 2.8T
3 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Forge Bypass Valve Cobalt/HHR TC
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x 9-3 ng900 Hood Protection Strip
1 x PPC 3 Volvo Diagnostic System
2 x Oil Cap GM "HHR"
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x 9000 Intercooler ETS
1 x Crush Sleeve F35 F25
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x 9-5 Blend Flap Limit Lever 99-04
3 x Steering Rod Bushings NG900/93
2 x Floormats BSR 9-3 99-02 900 94-98
1 x Optical Cable Connector (Onstar Delete)
$62,291.20
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail