$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Flywheel Twin Disk 7.25in B2xx
3 x Replacement Flywheel Insert NG900/9-3
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Transmission Nut F35 F25
3 x Shifter Top Ghost Logo
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Alu Hybrid Flywheel For NG900/9-3
3 x Slave Cyl
1 x Aluminum Flywheel For NG900/9-3
1 x Universal / Special Request
1 x Moog Ball Joint
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Oil Cooler Adaptor B2X5
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Steering Rod Bushings NG900/93
2 x 9-3/NG900 Shift Knobs Leather
1 x 20th Viggen logo Shifter Top
1 x 9-3 Rear Ashtray
2 x 9-3 ng900 radio wires
2 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9000 Shifter Bushing Repair Kit
1 x Limit Strap Coilover Add On Kit
2 x B207 Coolant Cap
1 x SCNA Christmas Calendar
1 x Con Rods V6 2.8L 155.8mm
4 x Replacement V6 Coolant Cap
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Troll Head Plug
1 x Coreganizer
1 x Flex Pipe 900 94-98 9-3 99-02
1 x 9-5 Aero Sill Protection
1 x Machined Control Arm Kit
2 x V6 Tank Float - SparePart
2 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x B207 Upper Radiator Coolant T
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Viggen Clutch Kit 99-02
1 x Midpipe 2.8T FWD (2wd)
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Shifter Mount Kit 93ss
1 x Rear Engine Mount 4cyl
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x BSR Optiflow Intake 4cyl w SAI
2 x BSR Optiflow Intake 4cyl
1 x Injectors 175hp Stg3 (Set4)
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
3 x Weld Bungs -Taper- Race Only
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Aero Clutch Kit 9-5
1 x BSR 9-5 260Hp 2006-
1 x Clear Little Fender Blinkers Factory Saab
1 x Steering Coupler 9-3 99-02
1 x Balance Shaft Tensioner Delete
1 x Fog light Replacement Panels
1 x Head Bolt Washers
2 x IAT Weld Bung T5/Bosch
1 x Griffin logo Shifter Top
1 x Viggen Fog Air Intake
2 x Brake Vac pump seals
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Turbo to Downpipe Flange B207
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Throttle Bend for T5 94-99
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
2 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x BSR Optiflow Intake V6 2.8t
1 x Intake Flange B2x4 T5
1 x Basic Subframe Brace
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Rear Camber Shims Kit 6pcs
1 x PPC - Upgrade from stage 1 to stage 3
1 x Oil Filter Re-locator
1 x Sport Transmission Mount 9-3/900 (Automatic)
$18,045.38
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail