$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Rear Camber Shims Kit 6pcs
3 x Rear spring perches Adjustable NG900/9-3
1 x Flex Pipe 900 94-98 9-3 99-02
1 x 9-3/NG900 Shift Knobs Leather
1 x Replacement Hardware Pack 6-Point
2 x Griffin logo Shifter Top
2 x Downpipe Hardware Kit
1 x Adaptor Harness Handsfree 01-
2 x Crank Vent Kit #6 T7 4cyl
1 x Fuel Line Clip
1 x Direct Ignition T5 RED
2 x 9-3 99-02,03 CV Antenna Adaptor
4 x Rear Engine Mount 4cyl
2 x Exhaust Clamp Kit
2 x Remote Button NG900
1 x Crush Sleeve F35 F25
1 x Replacement Filter for Open air 9-3 T7
1 x Fog light 9-3 left 99-00
1 x Viggen Fog Air Intake
3 x Clear Little Fender Blinkers Factory Saab
1 x Throttle Bend for T5 94-99
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-3 ng900 Hood Protection Strip
1 x Fog light Replacement Panels
1 x Oil Cooler Adaptor B2X5
1 x PPC 3 Volvo Diagnostic System
1 x Fog light 9-3 Right 99-00
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Antenna Plug NG900/9-3 hatchback
1 x 9-3 /NG900 Grille
2 x T7 Injector Spacer Kit
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Slave Cyl
3 x Shifter Top Ghost Logo
2 x Alu Hybrid Flywheel For NG900/9-3
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x Head Stud Kit all 4cyl
2 x c900 Performance Brake lines
1 x Replacement V6 Coolant Cap
1 x Moog Ball Joint
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Fuel Pressure Regulator 4.0 bar
1 x PPC - Upgrade from stage 1 to stage 3
1 x Rivetnuts Pair (2pcs)
1 x Intake Flange B2x4 T5
1 x Injectors Green Giant 42lb (set 4)
1 x Map/MAT sensor weld bung
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x 9-3 / 900 Uprated Front ARB Bushings
1 x Limit Strap Coilover Add On Kit
1 x Coreganizer
2 x Throttle Body T7
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Turbo Bypass Valve
2 x Genuine Saab 4cyl Oil Filters
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Viggen Front Brake Disk Pair 308mm
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Aluminum Flywheel For NG900/9-3
1 x ARP Ring Gear Bolts F25/F35
1 x Flywheel Twin Disk 7.25in B2xx
1 x Replacement Flywheel Insert NG900/9-3
1 x Mass Airflow Meter T7
1 x Air Filter 06 version (All 9-5)
1 x Cabin Vent Fan
1 x Filter 9-5 Cabin Air
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Headbolts (New Style)
1 x Direct Ignition T7 Black
1 x 20th Viggen logo Shifter Top
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Shifter Mount Kit Cobalt/ HHR
1 x Basic Subframe Brace
1 x 9000 High Performance Brake Line Kit '95-'98
$14,059.08
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail