$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Balance Shaft Tensioner Delete
3 x Flex Pipe 900 94-98 9-3 99-02
2 x Cat back for Viggen 2.5in
3 x Headbolts (New Style)
2 x JE Piston Rings 90.0mm 235/205
3 x Head Stud Kit all 4cyl
1 x Viggen Fog Air Intake
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Oil Cooler Adaptor B2X5
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Throttle Bend for T5 94-99
1 x T7 Injector Spacer Kit
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Injectors Siemens 60lb 630cc (set 4)
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Moog Ball Joint
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x PPC - Upgrade from stage 1 to stage 3
1 x IAT Weld Bung T5/Bosch
1 x Intake Flange B2x4 T5
1 x Injectors Green Giant 42lb (set 4)
1 x AEM Wideband Gauge Kit
1 x Map/MAT sensor weld bung
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Rivetnuts Pair (2pcs)
1 x Universal / Special Request
1 x Fuel Pressure Regulator 4.0 bar
1 x Head Bolt Washers
1 x PPC 3 Volvo Diagnostic System
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Steering Coupler 9-3 99-02
1 x Steering Rod Bushings NG900/93
1 x Rear Camber Shims Kit 6pcs
1 x Rear spring perches Adjustable NG900/9-3
1 x Basic Subframe Brace
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Machined Control Arm Kit
1 x Limit Strap Coilover Add On Kit
1 x Oil Cap GM "HHR"
1 x Slave Cyl
1 x Aluminum Flywheel For NG900/9-3
1 x K&N Filter Service Kit
2 x Shift Rod Bushings
1 x c900 Performance Brake lines
1 x Saab black Keychain
1 x Antenna Plug NG900/9-3 hatchback
1 x Fog light 9-3 Right 99-00
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Viggen Front Brake Disk Pair 308mm
2 x Troll Head Plug
2 x T7 Head Plug NGK
1 x 9-3 Rear Ashtray
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x Oil Filter Re-locator
1 x MTF0063 Manual Gear oil
2 x Rod Bearings only Pauter Rods
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 20th Viggen logo Shifter Top
2 x Upgrade Valve Springs T5 Cars
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Exhaust manifold Stud Kit
1 x Coreganizer
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Adaptor Harness Handsfree 01-
1 x Griffin logo Shifter Top
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3/NG900 Shift Knobs Leather
1 x ARP Exhaust Manifold Stud kit Stainless
$12,866.85
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail