$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x c900 Performance Brake lines
5 x Brake Vac pump seals
7 x Shifter Mount Kit Cobalt/ HHR
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
3 x Oil Filter Re-locator
2 x Flywheel Twin Disk 7.25in B2xx
3 x Short Shifter HHR Cobalt F35 F40
1 x BSR 9-5 2010-2011 V6 300Hp
3 x Fuel Line Clip
8 x Exhaust manifold Stud Kit
4 x Mass Airflow Meter T7
2 x Direct Ignition T7 Black
8 x Downpipe Hardware Kit
5 x Flex Pipe 900 94-98 9-3 99-02
3 x Replacement Filter for Open air 9-3 T7
5 x Exhaust Clamp Kit
3 x 9-5 Textile Mats 98-07
4 x BBS Center Cap for 9-2x RK small caps
2 x Remote Button NG900
4 x Troll Head Plug
4 x Adaptor Harness Handsfree 01-
2 x Injectors Green Giant 42lb (set 4)
3 x Open Air Intake 9000 93-98
3 x Saab black Keychain
2 x 9000 Intercooler ETS
7 x Shift Rod Bushings
3 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
4 x PPC - Upgrade from stage 1 to stage 3
4 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
4 x K&N Filter Service Kit
2 x Mat Set Black Rubber 9-5 10-
2 x 9-5 Wheel 10-Spoke 16in.
5 x Oil Cap 9-3SS V6 "Griffin"
4 x Mat Set Textile Parchment 9-5 10-
2 x Mat Set Textile Jet Black 9-5 10-
1 x Storage Tray / Ashtray Kit 9-5 10-
6 x 20th Viggen logo Shifter Top
3 x AEM Wideband Gauge Kit
7 x Rivetnuts Pair (2pcs)
3 x 9-5 Aero Sill Protection
1 x Optical Cable Connector (Onstar Delete)
4 x ShortShift Kit 93ss
2 x Hood Emblem 9-3 SS/sc 03- All
1 x Front Camber Adjustment Bolts
1 x Con Rods V6 2.8L 155.8mm
3 x Shifter Mount Kit 93ss
1 x Ignition Coil 9-3SS 2.0t and 2.0T
4 x Torque Mount Insert V6 Manual (XWD and FWD)
2 x T7 Head Plug NGK
1 x Headlight Connector Repair Kit 9-3SS 9-5
4 x B207 Upper Radiator Coolant T
1 x B207 Coolant Cap
2 x Sparkplugs 9-3SS
6 x Clear Little Fender Blinkers Factory Saab
4 x Head Bolt Washers
4 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Weld Bungs -Taper- Race Only
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
5 x Rear spring perches Adjustable NG900/9-3
3 x Headbolts (New Style)
3 x Steering Coupler 9-3 99-02
2 x 9-5 Exhaust Flex Pipe Stainless
3 x Forge Bypass Valve Cobalt/HHR TC
4 x Oil Cap GM "HHR"
3 x Steering Rod Bushings NG900/93
2 x Front Camber Adjustment Bolts
2 x Machined Control Arm Kit
1 x Air Filter 06 version (All 9-5)
2 x Headlight Bulb H7 Longer Life
1 x Oil Pressure Switch
2 x Cabin Vent Fan
2 x Coolant Bypass Valve 9-5
2 x 9-5 Intercooler ETS
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
3 x Oil Cap 9-3SS "Ghost"
3 x Alu Hybrid Flywheel For NG900/9-3
1 x Aluminum Flywheel For NG900/9-3
3 x Slave Cyl
4 x Oil Cooler Adaptor B2X5
2 x Drop in Sport Filter 9-5
5 x T7 Injector Spacer Kit
1 x Quaife Differential 9-5 and Viggen (F35)
2 x Sport Transmission Mount 9-3/900 (Automatic)
7 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x 9-3 ng900 radio wires
4 x Intake Flange B2x4 T5
1 x JE Piston Rings 90.0mm 235/205
1 x Head Stud Kit all 4cyl
7 x Balance Shaft Tensioner Delete
5 x Fuel Pressure Regulator 4.0 bar
4 x Map/MAT sensor weld bung
3 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Injectors 175hp Stg3 (Set4)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
3 x Floormats BSR 9-5
3 x Turbo Bypass Valve
1 x Genuine Saab 4cyl Oil Filters
2 x Cigarette Lighter
2 x Custom Brake Lines RR 300mm Kit
2 x Crank Vent Kit #6 T7 4cyl
5 x Cat back for Viggen 2.5in
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Bulb Switch Light
3 x Shifter Top Ghost Logo
4 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x 9-5 Shift Knobs Leather
1 x Throttle Body T7
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
5 x Crush Sleeve F35 F25
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
3 x Rear Engine Mount 4cyl
2 x Injectors Siemens 60lb 630cc (set 4)
1 x ARP Exhaust Manifold Stud kit Stainless
1 x BSR 9-5 3.0T V6 200Hp
2 x MTF0063 Manual Gear oil
1 x BSR 9-5 260Hp 2006-
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
2 x BSR Optiflow Intake V6 2.8t
1 x BSR Optiflow Intake 4cyl w SAI
1 x Aero Clutch Kit 9-5
2 x 9000 Shifter Bushing Repair Kit
2 x Cat Back Exh for 9000 CS, CSE AERO
3 x ATF Saab 3309 (Automatic 02->)
2 x Mat Set Textile Shark Grey 9-5 10-
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Brembo Brake Kit 315mm 9-3 SS
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
4 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
4 x V6 Tank Float - SparePart
2 x Moog Ball Joint
1 x Downpipe 2.8T XWD (4wd)
4 x Oil Cap 9-3SS V6 "Ghost"
3 x Griffin logo Shifter Top
5 x T7 3.5 Bar Fuel Pressure Regulator
3 x Fog light 9-5 Aero 04-05, 06-08 All Left
3 x Viggen Fog Air Intake
2 x Fog light Replacement Panels 99-01
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Hood Emblem 9-5 All
4 x Throttle Bend for T5 94-99
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
4 x Shifter Alignment Pins (Set 2)
2 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Replacement Flywheel Insert NG900/9-3
1 x Viggen Clutch Kit 99-02
3 x Downpipe 2.8T FWD (2wd)
3 x v6 2.8t SAI Delete Kit
2 x Brembo Brake Kit 315mm 9-5 02-->
4 x Filter 9-5 Cabin Air
5 x IAT Weld Bung T5/Bosch
4 x Ignition Coil 9-3SS 2.8t and 2.8T
4 x Replacement V6 Coolant Cap
1 x v6 header flange
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Turbo to Downpipe Flange B207
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Midpipe 2.8T FWD (2wd)
2 x Turbo Conversion Pipe 900 9-3 T5
3 x v6oilcoolplate
1 x Limit Strap Coilover Add On Kit
2 x Replacement Hardware Pack 6-Point
2 x Upgrade Valve Springs T5 Cars
2 x Rear Camber Shims Kit 6pcs
2 x Transmission Nut F35 F25
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x 9-3 SS Akebono Rear Pads
3 x Sport Transmission Mount 9-5 (Manual) 1998-1999
3 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x 9000 High Performance Brake Line Kit '95-'98
2 x Floormats BSR 9-3 99-02 900 94-98
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Brembo Kit 315mm Hawk HPS Pads
1 x 3 Point Hardware
3 x 9-3 / 900 Uprated Front ARB Bushings
1 x 9-3 ng900 Hood Protection Strip
1 x Universal / Special Request
1 x Injectors Siemens 80lb 875cc (set 4)
1 x 4 Cyl 2.0 Coolant Tank
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Basic Subframe Brace
3 x BSR Optiflow Intake 4cyl
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
3 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
4 x T5 3.0 Bar Map Sensor Adaptor
1 x Viggen Front Brake Disk Pair 308mm
1 x 9-3/NG900 Shift Knobs Leather
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Midpipe 2.8T XWD (4wd)
$68,718.65
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail