$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Injectors 175hp Stg3 (Set4)
3 x InjectorDynamics 725cc For 2.8V6 (Set6)
10 x BSR Optiflow Intake 4cyl w SAI
7 x BSR Optiflow Intake 4cyl
7 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Oil Cap 9-3SS V6 "Griffin"
3 x Midpipe 2.8T FWD (2wd)
3 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Flywheel Twin Disk 7.25in B2xx
4 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
4 x IAT Weld Bung T5/Bosch
3 x Map/MAT sensor weld bung
2 x Metal Steering Wheel Buttons
1 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
2 x Shifter Alignment Pins (Set 2)
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Griffin logo Shifter Top
2 x PPC 3 Volvo Diagnostic System
1 x ShortShift Kit 93ss
2 x Torque Mount Insert V6 Manual (XWD and FWD)
2 x Shifter Mount Kit 93ss
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Front Camber Adjustment Bolts
3 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Viggen Titanium KeyChain
2 x Machined Control Arm Kit
1 x V6 Tank Float - SparePart
1 x 3 Point Hardware
2 x B207 Upper Radiator Coolant T
5 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
3 x BSR 9-5 2010-2011 V6 300Hp
3 x BSR 9-5 3.0T V6 200Hp
4 x BSR Optiflow Intake V6 2.8t
3 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
3 x Midpipe 2.8T XWD (4wd)
3 x BSR Optiflow Replacement Filter V6 2.8
3 x Con Rods V6 2.8L 155.8mm
1 x 9-5 Aero Sill Protection
3 x Downpipe 2.8T XWD (4wd)
3 x B207 Coolant Cap
2 x Moog Ball Joint
4 x Downpipe 2.8T FWD (2wd)
2 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
2 x Genuine Saab 4cyl Oil Filters
1 x Slave Cyl
1 x Crush Sleeve F35 F25
2 x Sport Transmission Mount 9-5 (Manual) 1998-1999
2 x 9-5 Blend Flap Limit Lever 99-04
3 x 9-5 Exhaust Flex Pipe Stainless
6 x Shift Rod Bushings
1 x Cabin Vent Fan
1 x Fuel Line Clip
2 x Coolant Bypass Valve 9-5
4 x Clear Little Fender Blinkers Factory Saab
2 x Crank Vent Kit #6 T7 4cyl
1 x 9-5 Open Air Prefilter
1 x Spec Light Flywheel For 9-5 4cyl 99-09
2 x Air Filter 06 version (All 9-5)
1 x Oil Pressure Switch
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Aero Clutch Kit 9-5
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Downpipe Hardware Kit
2 x BSR 9-5 260Hp 2006-
1 x Hood Emblem 9-5 All
2 x Head Stud Kit all 4cyl
2 x Adaptor Harness Handsfree 01-
2 x Forge Bypass Valve Cobalt/HHR TC
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Injectors Siemens 80lb 875cc (set 4)
3 x Head Bolt Washers
2 x Intake Flange B2x4 T5
2 x Floormats BSR 9-3SS/SC
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Injectors Green Giant 42lb (set 4)
2 x Universal / Special Request
2 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Antenna Plug NG900/9-3 hatchback
1 x Flex Pipe 900 94-98 9-3 99-02
2 x Mass Airflow Meter T7
2 x Basic Subframe Brace
2 x Rear Engine Mount 4cyl
1 x Viggen Fog Air Intake
2 x T7 Head Plug NGK
1 x Weld Bungs -Taper- Race Only
1 x Short Shifter HHR Cobalt F35 F40
2 x Steering Coupler 9-3 99-02
1 x Viggen Front Brake Disk Pair 308mm
3 x 9000 Shifter Bushing Repair Kit
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x Coreganizer
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x Shifter Mount Kit Cobalt/ HHR
2 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Limit Strap Coilover Add On Kit
1 x Rivetnuts Pair (2pcs)
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Cat back for Viggen 2.5in
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Brake Vac pump seals
3 x Rear Camber Shims Kit 6pcs
1 x 9-5 High Performance Brake Line Kit
1 x Troll Head Plug
1 x Filter 9-5 Cabin Air
2 x Oil Cap 9-3SS V6 "Ghost"
2 x Fog light Replacement Panels 99-01
1 x Valve Cover Gasket Set 4cyl
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x v6 2.8t SAI Delete Kit
1 x Turbo Bypass Valve
1 x Replacement Hardware Pack 6-Point
1 x Front Camber Adjustment Bolts
1 x SCNA Christmas Calendar
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Transmission Nut F35 F25
1 x Shifter Top Ghost Logo
1 x Rear spring perches Adjustable NG900/9-3
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Oil Cap GM "HHR"
1 x 9-3/NG900 Shift Knobs Leather
1 x Balance Shaft Tensioner Delete
$49,881.79
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail