$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
6 x Clear Little Fender Blinkers Factory Saab
3 x 9-5 Aero Sill Protection
3 x PPC 3 Volvo Diagnostic System
5 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
3 x Limit Strap Coilover Add On Kit
2 x SCNA Christmas Calendar
3 x T7 Head Plug NGK
3 x 9000 Shifter Bushing Repair Kit
3 x Con Rods V6 2.8L 155.8mm
1 x Adaptor Harness Handsfree 01-
1 x Coreganizer
2 x 9-3/NG900 Shift Knobs Leather
1 x Flywheel Twin Disk 7.25in B2xx
2 x Machined Control Arm Kit
2 x 9-3 99-02,03 CV Antenna Adaptor
3 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x ATF Saab 3309 (Automatic 02->)
2 x Front Camber Adjustment Bolts
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Direct Ignition T7 Black
4 x 5d Rear Window repair kit 94-02 900/9-3/9-5
3 x Crank Vent Kit #6 T7 4cyl
3 x 9-5 Blend Flap Limit Lever 99-04
3 x Head Stud Kit all 4cyl
2 x 9-5 Exhaust Flex Pipe Stainless
3 x Fuel Line Clip
1 x Headlight Bulb H7 Longer Life
4 x Crush Sleeve F35 F25
2 x Genuine Saab 4cyl Oil Filters
2 x 4340 Connecting Rods B204 B235
4 x Downpipe Hardware Kit
1 x Rear Camber Shims Kit 6pcs
3 x Headbolts (New Style)
1 x 20th Viggen logo Shifter Top
2 x Oil Filter Re-locator
2 x Air Filter 06 version (All 9-5)
4 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x JE Piston Rings 90.0mm 235/205
2 x Coolant Bypass Valve 9-5
2 x Mass Airflow Meter T7
1 x Balance Shaft Tensioner Delete
2 x 9-5 Open Air Prefilter
2 x Remote Button NG900
2 x Turbo Conversion Pipe 900 9-3 T5
4 x PPC - Upgrade from stage 1 to stage 3
1 x Hood Emblem 9-5 All
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
3 x Exhaust Clamp Kit
2 x Cat back for Viggen 2.5in
4 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
4 x Flex Pipe 900 94-98 9-3 99-02
1 x Direct Ignition T5 RED
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Oil Cooler Adaptor B2X5
3 x Fog light Replacement Panels 99-01
2 x T7 Injector Spacer Kit
2 x Fog light 9-5 Aero 04-05, 06-08 All Right
3 x ARP Exhaust Manifold Stud kit Stainless
3 x Rear Engine Mount 4cyl
4 x Exhaust manifold Stud Kit
1 x Replacement Hardware Pack 6-Point
2 x Throttle Bend for T5 94-99
3 x T7 3.5 Bar Fuel Pressure Regulator
1 x Replacement Filter for Open air 9-3 T7
1 x Viggen Fog Air Intake
2 x Fog light 9-3 Right 99-00
1 x 9-3 ng900 Hood Protection Strip
3 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Slave Cyl
2 x Fog light Replacement Panels
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
4 x Shift Rod Bushings
1 x 9-3 /NG900 Grille
1 x 9-5 Intercooler ETS
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Downpipe 2.8T XWD (4wd)
1 x Oil Cap 9-3SS V6 "Griffin"
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Shifter Mount Kit 93ss
3 x BSR Optiflow Intake 4cyl
1 x Brake Vac pump seals
3 x AEM Wideband Gauge Kit
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x Rivetnuts Pair (2pcs)
3 x Moog Ball Joint
1 x MTF0063 Manual Gear oil
2 x 9000 Intercooler ETS
1 x 9000 High Performance Brake Line Kit '95-'98
2 x Cat Back Exh for 9000 CS, CSE AERO
2 x Injectors Green Giant 42lb (set 4)
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Fuel Pressure Regulator 4.0 bar
2 x Intake Flange B2x4 T5
3 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x IAT Weld Bung T5/Bosch
3 x 9-3 Rear Ashtray
2 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 ng900 radio wires
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
3 x Griffin logo Shifter Top
3 x 9-3 SS Akebono Rear Pads
1 x V6 Tank Float - SparePart
2 x Filter 9-5 Cabin Air
2 x Forge Bypass Valve Cobalt/HHR TC
2 x Oil Cap 9-3SS "Ghost"
1 x BSR Optiflow Replacement Filter V6 2.8
2 x 4 Cyl 2.0 Coolant Tank
1 x Injectors 175hp Stg3 (Set4)
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x BSR Optiflow Intake 4cyl w SAI
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x B207 Upper Radiator Coolant T
2 x Midpipe 2.0T 07-11 FWD (2wd)
3 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Fog light 9-3 left 99-00
2 x Mat Set Textile Parchment 9-5 10-
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
2 x Oil Cap 9-3SS V6 "Ghost"
2 x Ceramic Low Dust Brake Pads 9-3 SS
2 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Oil Pressure Switch
2 x Head Bolt Washers
2 x Map/MAT sensor weld bung
2 x Injectors Siemens 80lb 875cc (set 4)
1 x Brembo Brake Kit 315mm 9-3 SS
2 x c900 Performance Brake lines
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x Injectors Siemens 60lb 630cc (set 4)
2 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Hood Emblem 9-3 SS/sc 03- All
3 x Short Shifter HHR Cobalt F35 F40
1 x Troll Head Plug
1 x Turbo to Downpipe Flange B207
1 x Floormats BSR 9-5
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Weld Bungs -Taper- Race Only
2 x Open Air Intake 9000 93-98
1 x Shifter Mount Kit Cobalt/ HHR
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x v6 2.8t SAI Delete Kit
1 x v6 header flange
1 x BSR Optiflow Intake V6 2.8t
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Steering Rod Bushings NG900/93
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Turbo Bypass Valve
$50,530.42
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail