$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Replacement V6 Coolant Cap
2 x 20th Viggen logo Shifter Top
4 x Steering Coupler 9-3 99-02
1 x IAT Weld Bung T5/Bosch
4 x T5 3.0 Bar Map Sensor Adaptor
2 x Rivetnuts Pair (2pcs)
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
4 x Injectors Green Giant 42lb (set 4)
3 x PPC - Upgrade from stage 1 to stage 3
3 x Map/MAT sensor weld bung
3 x Head Bolt Washers
4 x Universal / Special Request
3 x AEM Wideband Gauge Kit
4 x Moog Ball Joint
2 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Injectors Siemens 60lb 630cc (set 4)
5 x Intake Flange B2x4 T5
2 x MTF0063 Manual Gear oil
2 x K&N Filter Service Kit
3 x Shifter Alignment Pins (Set 2)
4 x ATF Saab 3309 (Automatic 02->)
3 x Crush Sleeve F35 F25
1 x Oil Cap 9-3SS "Ghost"
3 x Basic Subframe Brace
2 x Rear spring perches Adjustable NG900/9-3
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Shift Rod Bushings
2 x 9-3/NG900 Shift Knobs Leather
2 x Mass Airflow Meter T7
2 x Head Stud Kit all 4cyl
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Griffin logo Shifter Top
4 x Rear Engine Mount 4cyl
2 x Coreganizer
2 x Quaife Differential 9-5 and Viggen (F35)
4 x Exhaust Clamp Kit
1 x Crank Vent Kit #6 T7 4cyl
1 x Floormats BSR 9-3 99-02 900 94-98
1 x ARP Exhaust Manifold Stud kit Stainless
2 x Replacement Flywheel Insert NG900/9-3
1 x 9-3 Rear Ashtray
1 x ARP Ring Gear Bolts F25/F35
2 x Genuine Saab 4cyl Oil Filters
1 x Oil Filter Re-locator
1 x Balance Shaft Tensioner Delete
5 x Flex Pipe 900 94-98 9-3 99-02
2 x Oil Cooler Adaptor B2X5
1 x Headbolts (New Style)
1 x Aluminum Flywheel For NG900/9-3
2 x 9-3 ng900 radio wires
1 x Downpipe Hardware Kit
2 x Cat back for Viggen 2.5in
2 x Shifter Top Ghost Logo
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
3 x Transmission Nut F35 F25
2 x Remote Button NG900
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x JE Piston Rings 90.0mm 235/205
1 x 4340 Connecting Rods B204 B235
2 x Exhaust manifold Stud Kit
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Rod Bearings only Pauter Rods
3 x Direct Ignition T5 RED
3 x Turbo Conversion Pipe 900 9-3 T5
1 x Viggen Fog Air Intake
2 x T7 Injector Spacer Kit
1 x Replacement Filter for Open air 9-3 T7
1 x 9-5 Wheel 5-Spoke Twin 17in
2 x Clear Little Fender Blinkers Factory Saab
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x Antenna Plug NG900/9-3 hatchback
1 x 9-5 Shift Knobs Leather
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 Rear Brake rotor See Description
1 x Air Filter 06 version (All 9-5)
3 x 9-3 /NG900 Grille
1 x Fog light 9-3 left 99-00
1 x Fog light 9-3 Right 99-00
2 x 9-3 ng900 Hood Protection Strip
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x 9-5 Aero Sill Protection
2 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x Fog light Replacement Panels
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x 9-5 Textile Mats 98-07
1 x Aero Clutch Kit 9-5
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Saab black Keychain
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Slave Cyl
1 x Torque Mount Insert V6 Manual (XWD and FWD)
2 x Weld Bungs -Taper- Race Only
2 x Rear Camber Shims Kit 6pcs
2 x Injectors Siemens 80lb 875cc (set 4)
1 x Troll Head Plug
1 x Turbo Bypass Valve
2 x Direct Ignition T7 Black
1 x Rear Pedestal Spoiler 9-3 SS
1 x Sparkplugs 9-3SS
1 x Optical Cable Connector (Onstar Delete)
1 x Headlight Bulb H7 Longer Life
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Throttle Bend for T5 94-99
1 x Throttle Body T7
1 x Mat Set Textile Jet Black 9-5 10-
1 x Rear Brake Pads 9-5 Later Style
1 x Mat Set Black Rubber 9-5 10-
1 x Cigarette Lighter
1 x Midpipe 2.8T FWD (2wd)
1 x Metal Steering Wheel Buttons
1 x Bulb Switch Light
1 x Cabin Vent Fan
2 x Front Brake Pads 9-5 9-3 900 LOW DUST
2 x Viggen Front Brake Disk Pair 308mm
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x Fuel Pressure Regulator 4.0 bar
1 x Alu Hybrid Flywheel For NG900/9-3
1 x BSR 9-5 3.0T V6 200Hp
1 x v6 header flange
1 x Shifter Mount Kit Cobalt/ HHR
1 x T7 Head Plug NGK
1 x Upgrade Valve Springs T5 Cars
1 x 3 Point Hardware
1 x BSR 9-5 260Hp 2006-
1 x Replacement Hardware Pack 6-Point
1 x Shifter Mount Kit 93ss
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Midpipe 2.8T XWD (4wd)
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Adaptor Harness Handsfree 01-
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x 9000 Intercooler ETS
1 x Sport Transmission Mount 9-3/900 (Automatic)
$34,191.94
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail