$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Front Camber Adjustment Bolts
3 x Shifter Mount Kit 93ss
3 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x Optical Cable Connector (Onstar Delete)
2 x 3 Point Hardware
2 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Brake Vac pump seals
2 x Rear Rotors PAIR 278mm Plain (Code: BA)
2 x V6 Tank Float - SparePart
1 x Replacement V6 Coolant Cap
1 x c900 Performance Brake lines
2 x Limit Strap Coilover Add On Kit
1 x Con Rods V6 2.8L 155.8mm
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Rivetnuts Pair (2pcs)
1 x Map/MAT sensor weld bung
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x IAT Weld Bung T5/Bosch
1 x Injectors Green Giant 42lb (set 4)
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x 20th Viggen logo Shifter Top
1 x MTF0063 Manual Gear oil
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Replacement Hardware Pack 6-Point
1 x Mass Airflow Meter T7
1 x Steering Rod Bushings NG900/93
1 x Viggen Fog Air Intake
1 x Balance Shaft Tensioner Delete
1 x T7 Head Plug NGK
1 x Remote Button NG900
1 x Genuine Saab 4cyl Oil Filters
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Slave Cyl
1 x ARP Ring Gear Bolts F25/F35
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Aluminum Flywheel For NG900/9-3
1 x Replacement Flywheel Insert NG900/9-3
1 x 9-3 ng900 Hood Protection Strip
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Fog light 9-3 left 99-00
1 x Exhaust Clamp Kit
1 x PPC - Upgrade from stage 1 to stage 3
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Fog light Replacement Panels
1 x 9-3 /NG900 Grille
1 x Cat back for Viggen 2.5in
2 x Exhaust manifold Stud Kit
1 x Fog light 9-3 Right 99-00
1 x Adaptor Harness Handsfree 01-
1 x Coreganizer
1 x 9-3/NG900 Shift Knobs Leather
1 x Griffin logo Shifter Top
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-3 Rear Ashtray
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 SS Akebono Rear Pads
1 x ShortShift Kit 93ss
2 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x Clear Little Fender Blinkers Factory Saab
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
2 x Brembo Brake Kit 315mm 9-3 SS
1 x Rear Camber Shims Kit 6pcs
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 9-3 ng900 radio wires
1 x Saab black Keychain
1 x Cabin Vent Fan
1 x Aero Clutch Kit 9-5
1 x 9-5 Intercooler ETS
1 x Air Filter 06 version (All 9-5)
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x BSR Optiflow Intake 4cyl
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x Downpipe 2.8T FWD (2wd)
1 x Shifter Alignment Pins (Set 2)
1 x Floormats BSR 9-3SS/SC
1 x Moog Ball Joint
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x 9-5 Rear Brake rotor See Description
2 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Front Rotors PAIR 302mm Plain (Code: AB)
$19,968.85
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail