$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x c900 Performance Brake lines
5 x Oil Cap GM "HHR"
2 x Forge Bypass Valve Cobalt/HHR TC
4 x Intake Flange B2x4 T5
4 x MTF0063 Manual Gear oil
5 x Header Flange Stainless Blended Transition B2x4,B2x5
5 x IAT Weld Bung T5/Bosch
1 x Injectors Siemens 60lb 630cc (set 4)
4 x Head Bolt Washers
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
4 x Map/MAT sensor weld bung
3 x 9000 Shifter Bushing Repair Kit
3 x K&N Filter Service Kit
3 x Open Air Intake 9-3 00-02 and Viggen (All T7)
4 x Throttle Bend for T5 94-99
3 x 9-5 Blend Flap Limit Lever 99-04
4 x Antenna Plug NG900/9-3 hatchback
2 x Fog light 9-3 Right 99-00
3 x Clear Little Fender Blinkers Factory Saab
3 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x 9-3 ng900 radio wires
4 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
5 x 9-3 /NG900 Grille
3 x Front Camber Adjustment Bolts
4 x BSR 9-5 260Hp 2006-
3 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
3 x Rear Camber Shims Kit 6pcs
3 x Griffin logo Shifter Top
3 x 9-3/NG900 Shift Knobs Leather
2 x 9-3 Rear Ashtray
1 x Coreganizer
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
4 x Moog Ball Joint
3 x 9-3 SS Akebono Rear Pads
2 x Upgrade Valve Springs T5 Cars
4 x Downpipe Hardware Kit
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Shift Knobs Leather
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Saab black Keychain
1 x 9-5 Rear Brake rotor See Description
1 x 9-5 Textile Mats 98-07
1 x "Griffin" Valve stem caps
4 x 9-5 Aero Sill Protection
1 x Viggen Titanium KeyChain
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
3 x Steering Rod Bushings NG900/93
3 x Steering Coupler 9-3 99-02
4 x Limit Strap Coilover Add On Kit
2 x Rear Pedestal Spoiler 9-3 SS
1 x Bulb Switch Light
1 x Headlight Bulb H7 Longer Life
2 x Slave Cyl
1 x Crank Vent Kit #6 T7 4cyl
2 x Direct Ignition T7 Black
1 x Genuine Saab 4cyl Oil Filters
1 x Oil Pressure Switch
5 x Shifter Mount Kit 93ss
1 x ShortShift Kit 93ss
1 x Headbolts (New Style)
4 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Crush Sleeve F35 F25
8 x Shift Rod Bushings
2 x Coolant Bypass Valve 9-5
3 x BSR 9-5 2010-2011 V6 300Hp
1 x Cabin Vent Fan
1 x Mass Airflow Meter T7
2 x Fuel Line Clip
1 x Quaife Differential 9-5 and Viggen (F35)
2 x ARP Ring Gear Bolts F25/F35
1 x Rear Engine Mount 4cyl
3 x Alu Hybrid Flywheel For NG900/9-3
1 x Fog light Replacement Panels 99-01
4 x Shifter Top Ghost Logo
3 x Transmission Nut F35 F25
1 x Hood Emblem 9-5 All
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Aluminum Flywheel For NG900/9-3
1 x Replacement Flywheel Insert NG900/9-3
3 x Weld Bungs -Taper- Race Only
2 x Fuel Pressure Regulator 4.0 bar
2 x Shifter Mount Kit Cobalt/ HHR
1 x Front Camber Adjustment Bolts
1 x ARP Exhaust Manifold Stud kit Stainless
1 x 3 Point Hardware
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
5 x Shifter Alignment Pins (Set 2)
6 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
2 x BSR Optiflow Replacement Filter V6 2.8
2 x Oil Cooler Adaptor B2X5
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x ATF Saab 3309 (Automatic 02->)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Rear spring perches Adjustable NG900/9-3
2 x Downpipe 2.8T FWD (2wd)
1 x Machined Control Arm Kit
1 x Brake Vac pump seals
2 x Turbo Conversion Pipe 900 9-3 T5
2 x Basic Subframe Brace
2 x Exhaust manifold Stud Kit
2 x Replacement Hardware Pack 6-Point
1 x BSR Optiflow Intake 4cyl
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x Midpipe 2.8T FWD (2wd)
2 x T7 Injector Spacer Kit
1 x BSR Optiflow Intake 4cyl w SAI
2 x Downpipe 2.8T XWD (4wd)
2 x Balance Shaft Tensioner Delete
2 x T7 3.5 Bar Fuel Pressure Regulator
2 x B207 Upper Radiator Coolant T
1 x Brembo Brake Kit 315mm 9-5 02-->
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
3 x Brembo Brake Kit 315mm 9-3 SS
2 x Viggen Fog Air Intake
2 x Midpipe 2.8T XWD (4wd)
3 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x AEM Wideband Gauge Kit
2 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x Replacement Filter for Open air 9-3 T7
2 x Mat Set Textile Shark Grey 9-5 10-
2 x Storage Tray / Ashtray Kit 9-5 10-
2 x Sport Transmission Mount 9-3/900 (Automatic)
3 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 4340 Connecting Rods B204 B235
2 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
5 x PPC - Upgrade from stage 1 to stage 3
1 x Drop in Sport Filter 9-5
1 x v6 2.8t SAI Delete Kit
4 x Custom Brake Lines Brembo 315mm 9-3SS/SC
2 x Oil Cap 9-3SS V6 "Griffin"
2 x 9-3 ng900 Hood Protection Strip
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Exhaust Clamp Kit
1 x Fog light 9-3 left 99-00
1 x 9000 High Performance Brake Line Kit '95-'98
2 x Custom Brake Lines RR 300mm Kit
1 x Adaptor Harness Handsfree 01-
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Remote Button NG900
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Fog light Replacement Panels
2 x Viggen Front Brake Disk Pair 308mm
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Viggen Clutch Kit 99-02
2 x Rear Rotors PAIR 292mm XWD (Code: BC)
1 x Cat back for Viggen 2.5in
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Mat Set Textile Parchment 9-5 10-
1 x Con Rods V6 2.8L 155.8mm
2 x B207 Coolant Cap
1 x 4 Cyl 2.0 Coolant Tank
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Front Rotors PAIR 302mm Plain (Code: AB)
1 x Rear Brake Pads 9-3 SS
2 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Filter 9-5 Cabin Air
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x V6 Tank Float - SparePart
1 x Oil Cap 9-3SS "Ghost"
1 x Oil Cap 9-3SS V6 "Ghost"
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x v6oilcoolplate
1 x Turbo to Downpipe Flange B207
2 x Universal / Special Request
1 x 9-5 Wheel 5-Spoke Twin 17in
$62,957.75
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail