$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Viggen Titanium KeyChain
3 x Saab black Keychain
2 x SCNA Christmas Calendar
2 x Limit Strap Coilover Add On Kit
1 x Con Rods V6 2.8L 155.8mm
5 x Moog Ball Joint
2 x B207 Coolant Cap
3 x AEM Wideband Gauge Kit
3 x Fuel Pressure Regulator 4.0 bar
3 x Head Bolt Washers
4 x Injectors Siemens 80lb 875cc (set 4)
2 x Map/MAT sensor weld bung
5 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
3 x Intake Flange B2x4 T5
3 x Universal / Special Request
3 x Header Flange Stainless Blended Transition B2x4,B2x5
5 x Shifter Alignment Pins (Set 2)
3 x MTF0063 Manual Gear oil
3 x ATF Saab 3309 (Automatic 02->)
3 x Clear Little Fender Blinkers Factory Saab
2 x c900 Performance Brake lines
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Floormats BSR 9-3SS/SC
1 x 9-5 Aero Sill Protection
2 x Brake Vac pump seals
1 x Front Camber Adjustment Bolts
1 x Optical Cable Connector (Onstar Delete)
1 x V6 Tank Float - SparePart
1 x Rear Camber Shims Kit 6pcs
2 x Crush Sleeve F35 F25
1 x Machined Control Arm Kit
2 x Shift Rod Bushings
1 x Griffin logo Shifter Top
1 x Transmission Nut F35 F25
2 x Oil Cap 9-3SS V6 "Griffin"
1 x Oil Filter Re-locator
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Oil Cap GM "HHR"
1 x v6oilcoolplate
1 x Basic Subframe Brace
2 x v6 header flange
1 x Oil Cooler Adaptor B2X5
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Steering Coupler 9-3 99-02
1 x 20th Viggen logo Shifter Top
1 x B207 Upper Radiator Coolant T
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Cat Back Exh for 9000 CS, CSE AERO
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Open Air Intake 9000 93-98
1 x 9000 Intercooler ETS
3 x PPC - Upgrade from stage 1 to stage 3
3 x Weld Bungs -Taper- Race Only
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Injectors Green Giant 42lb (set 4)
3 x IAT Weld Bung T5/Bosch
2 x Injectors Siemens 60lb 630cc (set 4)
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Wheel 10-Spoke 16in.
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x BSR Optiflow Intake 4cyl w SAI
2 x Midpipe 2.8T FWD (2wd)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Exhaust manifold Stud Kit
1 x Cat back for Viggen 2.5in
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Antenna Plug NG900/9-3 hatchback
2 x 9-3 /NG900 Grille
2 x Fog light 9-3 left 99-00
2 x Fog light Replacement Panels
1 x Mat Set Textile Shark Grey 9-5 10-
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Fog light Replacement Panels 99-01
1 x 9-5 Textile Mats 98-07
1 x Cigarette Lighter
1 x Shifter Mount Kit 93ss
1 x Steering Rod Bushings NG900/93
1 x Short Shifter HHR Cobalt F35 F40
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Shifter Mount Kit Cobalt/ HHR
1 x Shifter Top Ghost Logo
1 x Metal Steering Wheel Buttons
1 x Adaptor Harness Handsfree 01-
1 x K&N Filter Service Kit
1 x Downpipe Hardware Kit
1 x Forge Bypass Valve Cobalt/HHR TC
1 x 4340 Connecting Rods B204 B235
1 x Viggen Fog Air Intake
1 x BSR Optiflow Replacement Filter V6 2.8
2 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x Rivetnuts Pair (2pcs)
1 x Replacement Hardware Pack 6-Point
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Downpipe 2.8T FWD (2wd)
1 x T7 Head Plug NGK
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x Troll Head Plug
1 x Rod Bearings only Pauter Rods
1 x Turbo to Downpipe Flange B207
1 x Brembo Kit 315mm Hawk HPS Pads
1 x 9-5 High Performance Brake Line Kit
1 x Slave Cyl
2 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Throttle Bend for T5 94-99
1 x Oil Cap 9-3SS "Ghost"
1 x Exhaust Clamp Kit
$22,863.17
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail