$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
5 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Throttle Bend for T5 94-99
3 x T7 Injector Spacer Kit
1 x Fog light Replacement Panels
2 x 9-3 ng900 Hood Protection Strip
1 x Fog light 9-3 left 99-00
3 x Clear Little Fender Blinkers Factory Saab
2 x Fog light 9-3 Right 99-00
1 x Downpipe Hardware Kit
1 x JE Piston Rings 90.0mm 235/205
1 x Replacement Flywheel Insert NG900/9-3
2 x Mass Airflow Meter T7
1 x Replacement Hardware Pack 6-Point
2 x Rear Engine Mount 4cyl
1 x 4340 Connecting Rods B204 B235
1 x Flywheel Twin Disk 7.25in B2xx
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Flex Pipe 900 94-98 9-3 99-02
2 x PPC - Upgrade from stage 1 to stage 3
2 x K&N Filter Service Kit
2 x ATF Saab 3309 (Automatic 02->)
1 x Shifter Alignment Pins (Set 2)
1 x Cat back for Viggen 2.5in
1 x Viggen Titanium KeyChain
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Injectors Green Giant 42lb (set 4)
2 x Con Rods V6 2.8L 155.8mm
2 x 20th Viggen logo Shifter Top
1 x 9000 Shifter Bushing Repair Kit
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x MTF0063 Manual Gear oil
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 9-5 Aero Sill Protection
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Custom Brake Lines RR 300mm Kit
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x BBS Center Cap for 9-2x RK small caps
2 x PPC 3 Volvo Diagnostic System
1 x BSR 9-5 3.0T V6 200Hp
1 x BSR 9-5 2010-2011 V6 300Hp
1 x BSR Optiflow Intake 4cyl w SAI
1 x BSR 9-5 260Hp 2006-
1 x BSR Optiflow Intake 4cyl
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x BSR Optiflow Intake V6 2.8t
1 x Basic Subframe Brace
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Shift Rod Bushings
1 x Front Camber Adjustment Bolts
1 x Mat Set Textile Parchment 9-5 10-
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x 4 Cyl 2.0 Coolant Tank
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Viggen Fog Air Intake
2 x V6 Tank Float - SparePart
1 x Sparkplugs 9-3SS
1 x Map/MAT sensor weld bung
1 x v6 2.8t SAI Delete Kit
1 x Balance Shaft Tensioner Delete
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x T7 3.5 Bar Fuel Pressure Regulator
2 x Replacement V6 Coolant Cap
1 x Moog Ball Joint
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-5 Open Air Prefilter
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Limit Strap Coilover Add On Kit
1 x Midpipe 2.8T XWD (4wd)
1 x Intake Flange B2x4 T5
1 x Rear spring perches Adjustable NG900/9-3
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Griffin logo Shifter Top
1 x Rear Camber Shims Kit 6pcs
$16,436.52
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail