$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x 9-3 ng900 Hood Protection Strip
3 x 9-3 /NG900 Grille
2 x Antenna Plug NG900/9-3 hatchback
1 x Cat back for Viggen 2.5in
1 x Exhaust manifold Stud Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Exhaust Clamp Kit
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Flex Pipe 900 94-98 9-3 99-02
2 x Sport Transmission Mount 9-3/900 (Automatic)
3 x Shifter Top Ghost Logo
2 x Rear Engine Mount 4cyl
2 x Shift Rod Bushings
1 x Slave Cyl
2 x Flywheel Twin Disk 7.25in B2xx
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Transmission Nut F35 F25
1 x Aluminum Flywheel For NG900/9-3
1 x Replacement Flywheel Insert NG900/9-3
1 x Quaife Differential 9-5 and Viggen (F35)
1 x 4340 Connecting Rods B204 B235
1 x T7 Head Plug NGK
1 x Headbolts (New Style)
2 x PPC - Upgrade from stage 1 to stage 3
1 x Oil Filter Re-locator
1 x JE Piston Rings 90.0mm 235/205
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Turbo Conversion Pipe 900 9-3 T5
1 x Saab black Keychain
2 x Shifter Alignment Pins (Set 2)
1 x K&N Filter Service Kit
2 x 9-5 Aero Sill Protection
1 x Mat Set Textile Jet Black 9-5 10-
1 x Storage Tray / Ashtray Kit 9-5 10-
2 x Mat Set Textile Parchment 9-5 10-
1 x Mat Set Black Rubber 9-5 10-
1 x Oil Cap 9-3SS V6 "Ghost"
2 x Mat Set Textile Shark Grey 9-5 10-
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Basic Subframe Brace
2 x Fog light 9-3 Right 99-00
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Clear Little Fender Blinkers Factory Saab
1 x Fog light 9-3 left 99-00
1 x Fog light Replacement Panels
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Optical Cable Connector (Onstar Delete)
2 x Cat Back Exh for 9000 CS, CSE AERO
1 x 4 Cyl 2.0 Coolant Tank
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Steering Rod Bushings NG900/93
1 x Midpipe 2.8T XWD (4wd)
1 x Viggen Fog Air Intake
1 x Throttle Bend for T5 94-99
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x T7 Injector Spacer Kit
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Fog light Replacement Panels 99-01
1 x ATF Saab 3309 (Automatic 02->)
1 x Shifter Mount Kit Cobalt/ HHR
1 x Open Air Intake 9000 93-98
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
2 x Crush Sleeve F35 F25
1 x Replacement V6 Coolant Cap
1 x 9-3 SS Akebono Rear Pads
1 x Moog Ball Joint
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Upgrade Valve Springs T5 Cars
1 x V6 Tank Float - SparePart
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Fuel Pressure Regulator 4.0 bar
1 x Front Camber Adjustment Bolts
1 x ARP Ring Gear Bolts F25/F35
1 x 9000 Shifter Bushing Repair Kit
1 x 9000 High Performance Brake Line Kit '95-'98
1 x 9-5 Wheel 10-Spoke 16in.
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
$19,326.81
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail