$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
3 x Shifter Mount Kit Cobalt/ HHR
2 x Short Shifter HHR Cobalt F35 F40
1 x Injectors Siemens 60lb 630cc (set 4)
1 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
1 x Shifter Alignment Pins (Set 2)
1 x MTF0063 Manual Gear oil
1 x B207 Coolant Cap
1 x 9000 Shifter Bushing Repair Kit
2 x Replacement V6 Coolant Cap
1 x Con Rods V6 2.8L 155.8mm
1 x T7 Head Plug NGK
1 x Troll Head Plug
2 x Clear Little Fender Blinkers Factory Saab
2 x 9-5 Aero Sill Protection
2 x BSR 9-5 2010-2011 V6 300Hp
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Mat Set Black Rubber 9-5 10-
1 x Mat Set Textile Shark Grey 9-5 10-
2 x Storage Tray / Ashtray Kit 9-5 10-
2 x Mat Set Textile Parchment 9-5 10-
1 x Oil Cap 9-3SS V6 "Griffin"
1 x PPC 3 Volvo Diagnostic System
1 x Mat Set Textile Jet Black 9-5 10-
2 x Viggen Fog Air Intake
1 x Steering Rod Bushings NG900/93
1 x Rear Camber Shims Kit 6pcs
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Basic Subframe Brace
1 x Machined Control Arm Kit
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cooler Adaptor B2X5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x T7 Injector Spacer Kit
2 x 9-3 / 900 Uprated Front ARB Bushings
1 x Rear spring perches Adjustable NG900/9-3
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Floormats BSR 9-3 99-02 900 94-98
2 x 20th Viggen logo Shifter Top
1 x Fog light 9-3 Right 99-00
1 x Alu Hybrid Flywheel For NG900/9-3
1 x 9-3 /NG900 Grille
1 x 4340 Connecting Rods B204 B235
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Fog light 9-3 left 99-00
1 x Exhaust Clamp Kit
1 x Quaife Differential 9-5 and Viggen (F35)
3 x Shift Rod Bushings
1 x Rod Bearings only Pauter Rods
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Rear Engine Mount 4cyl
1 x Balance Shaft Tensioner Delete
4 x Adaptor Harness Handsfree 01-
1 x Oil Cap GM "HHR"
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Exhaust manifold Stud Kit
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x 9-5 Blend Flap Limit Lever 99-04
1 x BSR Optiflow Replacement Filter V6 2.8
2 x 9-5 Textile Mats 98-07
1 x Front Camber Adjustment Bolts
1 x Floormats BSR 9-5
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Crank Vent Kit #6 T7 4cyl
1 x BSR Optiflow Intake 4cyl w SAI
1 x Fuel Line Clip
1 x Midpipe 2.8T FWD (2wd)
1 x V6 Tank Float - SparePart
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Sparkplugs 9-3SS
2 x Brake Vac pump seals
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Moog Ball Joint
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Downpipe Hardware Kit
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Steering Coupler 9-3 99-02
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Cigarette Lighter
1 x 9-5 Shift Knobs Leather
1 x ARP Exhaust Manifold Stud kit Stainless
1 x ARP Ring Gear Bolts F25/F35
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x PPC - Upgrade from stage 1 to stage 3
1 x Viggen Front Brake Disk Pair 308mm
1 x Head Stud Kit all 4cyl
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
$17,794.39
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail