$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Clear Little Fender Blinkers Factory Saab
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
3 x PPC 3 Volvo Diagnostic System
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x SCNA Christmas Calendar
1 x Saab black Keychain
1 x Viggen Titanium KeyChain
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Shifter Alignment Pins (Set 2)
1 x K&N Filter Service Kit
1 x Map/MAT sensor weld bung
1 x Rivetnuts Pair (2pcs)
1 x 9-5 Aero Sill Protection
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
3 x 9-5 Wheel 5-Spoke Twin 17in
1 x ATF Saab 3309 (Automatic 02->)
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Antenna Plug NG900/9-3 hatchback
1 x Aero Clutch Kit 9-5
1 x Injectors 175hp Stg3 (Set4)
1 x Downpipe 2.8T XWD (4wd)
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Front Camber Adjustment Bolts
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x 9-5 Shift Knobs Leather
1 x Shifter Top Ghost Logo
1 x Headbolts (New Style)
1 x Replacement Hardware Pack 6-Point
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x 9-3/NG900 Shift Knobs Leather
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Exhaust Clamp Kit
3 x Replacement V6 Coolant Cap
1 x Downpipe 2.8T FWD (2wd)
1 x Hood Emblem 9-3 SS/sc 03- All
2 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Shifter Mount Kit 93ss
1 x 4 Cyl 2.0 Coolant Tank
1 x ShortShift Kit 93ss
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Metal Steering Wheel Buttons
1 x 3 Point Hardware
1 x BSR Optiflow Intake 4cyl
2 x B207 Coolant Cap
2 x V6 Tank Float - SparePart
1 x Viggen Fog Air Intake
1 x MTF0063 Manual Gear oil
1 x AEM Wideband Gauge Kit
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x 9-3 SS Akebono Rear Pads
1 x Filter 9-5 Cabin Air
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Basic Subframe Brace
1 x Limit Strap Coilover Add On Kit
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Rear Pedestal Spoiler 9-3 SS
1 x Mat Set Textile Shark Grey 9-5 10-
1 x Rear Engine Mount 4cyl
1 x Optical Cable Connector (Onstar Delete)
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x PPC - Upgrade from stage 1 to stage 3
1 x Front Camber Adjustment Bolts
1 x Mat Set Black Rubber 9-5 10-
1 x Rear Rotors PAIR 292mm XWD (Code: BC)
$14,510.62
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail