$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
7 x Injectors Siemens 60lb 630cc (set 4)
5 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
8 x PPC - Upgrade from stage 1 to stage 3
1 x 9000 Shifter Bushing Repair Kit
2 x 3 Point Hardware
9 x IAT Weld Bung T5/Bosch
5 x Clear Little Fender Blinkers Factory Saab
5 x Map/MAT sensor weld bung
7 x Moog Ball Joint
5 x Head Bolt Washers
2 x T5 3.0 Bar Map Sensor Adaptor
3 x Intake Flange B2x4 T5
2 x Shifter Mount Kit Cobalt/ HHR
5 x Injectors Green Giant 42lb (set 4)
1 x K&N Filter Service Kit
4 x MTF0063 Manual Gear oil
1 x Viggen Titanium KeyChain
3 x Shifter Alignment Pins (Set 2)
2 x Saab black Keychain
1 x ATF Saab 3309 (Automatic 02->)
2 x SCNA Christmas Calendar
1 x Injectors Siemens 80lb 875cc (set 4)
3 x Limit Strap Coilover Add On Kit
2 x T7 Head Plug NGK
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
3 x Transmission Nut F35 F25
2 x 9-5 Aero Sill Protection
1 x 9-3 Rear Ashtray
2 x Shifter Top Ghost Logo
4 x Shift Rod Bushings
3 x Floormats BSR 9-3 99-02 900 94-98
3 x Coreganizer
1 x Slave Cyl
3 x Rear Engine Mount 4cyl
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Sport Transmission Mount 9-3/900 (Automatic)
1 x ARP Ring Gear Bolts F25/F35
2 x 9-3/NG900 Shift Knobs Leather
1 x Fog light 9-3 left 99-00
1 x Antenna Plug NG900/9-3 hatchback
2 x Quaife Differential 9-5 and Viggen (F35)
4 x 9-3 99-02,03 CV Antenna Adaptor
1 x Flywheel Twin Disk 7.25in B2xx
4 x Adaptor Harness Handsfree 01-
2 x 9-3 ng900 Hood Protection Strip
3 x 20th Viggen logo Shifter Top
2 x Aluminum Flywheel For NG900/9-3
2 x Fog light Replacement Panels
1 x 9-3 /NG900 Grille
5 x Exhaust manifold Stud Kit
1 x 9-5 Open Air Prefilter
4 x Ignition Coil 9-3SS 2.8t and 2.8T
3 x Flex Pipe 900 94-98 9-3 99-02
3 x Downpipe Hardware Kit
4 x Exhaust Clamp Kit
3 x Replacement V6 Coolant Cap
1 x Cat back for Viggen 2.5in
1 x Upgrade Valve Springs T5 Cars
2 x V6 Tank Float - SparePart
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x 9-3 SS Akebono Rear Pads
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x ARP Exhaust Manifold Stud kit Stainless
2 x T7 Injector Spacer Kit
1 x Filter 9-5 Cabin Air
1 x Rivetnuts Pair (2pcs)
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
4 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cooler Adaptor B2X5
3 x AEM Wideband Gauge Kit
1 x Turbo Conversion Pipe 900 9-3 T5
6 x Fuel Pressure Regulator 4.0 bar
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x Throttle Bend for T5 94-99
1 x Viggen Fog Air Intake
2 x BSR Optiflow Intake 4cyl w SAI
1 x Drop in Sport Filter 9-5
2 x 9-5 Textile Mats 98-07
2 x BSR Optiflow Intake 4cyl
2 x Direct Ignition T7 Black
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Head Stud Kit all 4cyl
1 x BSR Optiflow Intake V6 2.8t
1 x BSR 9-5 2010-2011 V6 300Hp
1 x BSR 9-5 3.0T V6 200Hp
1 x 9-5 Intercooler ETS
1 x BSR 9-5 260Hp 2006-
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Mass Airflow Meter T7
2 x Replacement Hardware Pack 6-Point
1 x Crush Sleeve F35 F25
1 x Bulb Switch Light
1 x Remote Button NG900
1 x Fuel Line Clip
2 x Direct Ignition T5 RED
1 x Genuine Saab 4cyl Oil Filters
2 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x 9-5 Shift Knobs Leather
1 x Front Camber Adjustment Bolts
1 x Cigarette Lighter
1 x Floormats BSR 9-5
1 x Fog light Replacement Panels 99-01
2 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Weld Bungs -Taper- Race Only
2 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x B207 Upper Radiator Coolant T
2 x Floormats BSR 9-3SS/SC
2 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x Hood Emblem 9-3 SS/sc 03- All
1 x Oil Cap 9-3SS V6 "Ghost"
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Balance Shaft Tensioner Delete
1 x Basic Subframe Brace
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Forge Bypass Valve Cobalt/HHR TC
1 x 4340 Connecting Rods B204 B235
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x PPC 3 Volvo Diagnostic System
1 x B207 Coolant Cap
1 x Crank Vent Kit #6 T7 4cyl
1 x Turbo Bypass Valve
2 x Griffin logo Shifter Top
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x Brake Vac pump seals
1 x Shifter Mount Kit 93ss
1 x JE Piston Rings 90.0mm 235/205
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Universal / Special Request
1 x Oil Cap GM "HHR"
1 x Metal Steering Wheel Buttons
1 x Steering Rod Bushings NG900/93
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
$40,539.78
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail