$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Injectors Siemens 80lb 875cc (set 4)
5 x Map/MAT sensor weld bung
6 x Header Flange 1/2in Blended Transition B2x4,B2x5
4 x Oil Cap GM "HHR"
1 x Exhaust manifold Stud Kit
4 x Head Bolt Washers
5 x Intake Flange B2x4 T5
3 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Injectors Siemens 60lb 630cc (set 4)
3 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
4 x Weld Bungs -Taper- Race Only
4 x Moog Ball Joint
4 x Fuel Pressure Regulator 4.0 bar
4 x T5 3.0 Bar Map Sensor Adaptor
4 x Injectors Green Giant 42lb (set 4)
2 x AEM Wideband Gauge Kit
1 x 9-5 Open Air Prefilter
1 x Replacement V6 Coolant Cap
2 x Upgrade Valve Springs T5 Cars
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x c900 Performance Brake lines
2 x MTF0063 Manual Gear oil
1 x Short Shifter HHR Cobalt F35 F40
1 x 9000 Intercooler ETS
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Open Air Intake 9000 93-98
2 x Shift Rod Bushings
2 x Crush Sleeve F35 F25
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9000 High Performance Brake Line Kit '95-'98
2 x 9000 Shifter Bushing Repair Kit
2 x Limit Strap Coilover Add On Kit
1 x Steering Rod Bushings NG900/93
1 x Head Stud Kit all 4cyl
1 x Oil Filter Re-locator
1 x Headbolts (New Style)
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x JE Piston Rings 90.0mm 235/205
1 x Balance Shaft Tensioner Delete
1 x 4340 Connecting Rods B204 B235
1 x T7 Head Plug NGK
1 x Rear Pedestal Spoiler 9-3 SS
1 x Rear spring perches Adjustable NG900/9-3
1 x Slave Cyl
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Direct Ignition T7 Black
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Basic Subframe Brace
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-3 SS Akebono Rear Pads
1 x Rod Bearings only Pauter Rods
1 x 9-3 /NG900 Grille
1 x Rear Engine Mount 4cyl
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Clear Little Fender Blinkers Factory Saab
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Universal / Special Request
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Cat back for Viggen 2.5in
1 x Shifter Mount Kit Cobalt/ HHR
1 x Downpipe Hardware Kit
1 x Remote Button NG900
2 x Turbo Bypass Valve
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Con Rods V6 2.8L 155.8mm
1 x v6oilcoolplate
1 x 3 Point Hardware
1 x Genuine Saab 4cyl Oil Filters
1 x Crank Vent Kit #6 T7 4cyl
1 x Mass Airflow Meter T7
1 x Exhaust Clamp Kit
1 x Replacement Hardware Pack 6-Point
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Optical Cable Connector (Onstar Delete)
1 x Floormats BSR 9-3SS/SC
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
$18,313.89
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail