$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Injectors Siemens 80lb 875cc (set 4)
3 x Fuel Pressure Regulator 4.0 bar
2 x Injectors Siemens 60lb 630cc (set 4)
4 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x 9-5 Aero Sill Protection
2 x 9000 Shifter Bushing Repair Kit
3 x Limit Strap Coilover Add On Kit
1 x Shifter Alignment Pins (Set 2)
1 x Shifter Mount Kit Cobalt/ HHR
1 x Saab black Keychain
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Con Rods V6 2.8L 155.8mm
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x BSR Optiflow Intake V6 2.8t
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
2 x Shift Rod Bushings
1 x Rear Pedestal Spoiler 9-3 SS
1 x ShortShift Kit 93ss
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
3 x Weld Bungs -Taper- Race Only
3 x PPC - Upgrade from stage 1 to stage 3
1 x MTF0063 Manual Gear oil
2 x Coreganizer
2 x Intake Flange B2x4 T5
1 x Moog Ball Joint
1 x Adaptor Harness Handsfree 01-
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x IAT Weld Bung T5/Bosch
1 x Mat Set Textile Jet Black 9-5 10-
1 x Mat Set Textile Shark Grey 9-5 10-
3 x Clear Little Fender Blinkers Factory Saab
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Genuine Saab 4cyl Oil Filters
1 x Mass Airflow Meter T7
1 x 9-3 Rear Ashtray
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Basic Subframe Brace
1 x Replacement Flywheel Insert NG900/9-3
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Rear Engine Mount 4cyl
2 x Headlight Bulb H7 Longer Life
2 x Flex Pipe 900 94-98 9-3 99-02
2 x 20th Viggen logo Shifter Top
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Replacement Filter for Open air 9-3 T7
1 x Steering Coupler 9-3 99-02
1 x Crank Vent Kit #6 T7 4cyl
1 x BSR 9-5 260Hp 2006-
1 x Air Filter 06 version (All 9-5)
2 x 9-3 ng900 radio wires
3 x Crush Sleeve F35 F25
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Rear Camber Shims Kit 6pcs
1 x Direct Ignition T7 Black
3 x T7 Injector Spacer Kit
1 x Slave Cyl
1 x 9-5 Shift Knobs Leather
2 x ARP Ring Gear Bolts F25/F35
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Floormats BSR 9-5
1 x Exhaust Clamp Kit
1 x Exhaust manifold Stud Kit
1 x Throttle Bend for T5 94-99
1 x Direct Ignition T5 RED
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Oil Cap GM "HHR"
1 x Oil Filter Re-locator
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x BSR Optiflow Intake 4cyl
1 x 3 Point Hardware
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Green Giant 42lb (set 4)
2 x Rivetnuts Pair (2pcs)
1 x Map/MAT sensor weld bung
1 x Universal / Special Request
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
3 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x v6 header flange
1 x Machined Control Arm Kit
1 x 9-5 Wheel 5-Spoke Twin 17in
$17,580.25
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail