$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x SCNA Christmas Calendar
1 x Saab black Keychain
2 x Oil Cap GM "HHR"
1 x Forge Bypass Valve Cobalt/HHR TC
3 x c900 Performance Brake lines
1 x Clear Little Fender Blinkers Factory Saab
2 x 9000 Shifter Bushing Repair Kit
1 x Troll Head Plug
1 x Con Rods V6 2.8L 155.8mm
3 x Limit Strap Coilover Add On Kit
1 x T7 Head Plug NGK
2 x MTF0063 Manual Gear oil
1 x ATF Saab 3309 (Automatic 02->)
1 x Shifter Alignment Pins (Set 2)
1 x K&N Filter Service Kit
4 x BBS Center Cap for 9-2x RK small caps
2 x 9-5 Wheel 10-Spoke 16in.
2 x Mat Set Textile Parchment 9-5 10-
1 x Oil Cap 9-3SS V6 "Griffin"
2 x Mat Set Textile Jet Black 9-5 10-
2 x 9-5 Wheel 5-Spoke Twin 17in
1 x Storage Tray / Ashtray Kit 9-5 10-
2 x Mat Set Textile Shark Grey 9-5 10-
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Mat Set Black Rubber 9-5 10-
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x Short Shifter HHR Cobalt F35 F40
1 x Basic Subframe Brace
1 x Shifter Mount Kit Cobalt/ HHR
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Cat back for Viggen 2.5in
1 x JE Piston Rings 90.0mm 235/205
1 x Injectors 175hp Stg3 (Set4)
1 x Rear Pedestal Spoiler 9-3 SS
1 x Direct Ignition T5 RED
1 x Head Bolt Washers
3 x Shift Rod Bushings
1 x Fog light Replacement Panels 99-01
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Moog Ball Joint
1 x Filter 9-5 Cabin Air
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Transmission Nut F35 F25
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Rivetnuts Pair (2pcs)
2 x 9-3 SS Akebono Rear Pads
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-5 Open Air Prefilter
1 x V6 Tank Float - SparePart
1 x v6 header flange
2 x Midpipe 2.8T XWD (4wd)
1 x Midpipe 2.8T FWD (2wd)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x BSR Optiflow Intake V6 2.8t
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x v6 2.8t SAI Delete Kit
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Machined Control Arm Kit
1 x Griffin logo Shifter Top
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Crank Vent Kit #6 T7 4cyl
1 x Exhaust manifold Stud Kit
1 x IAT Weld Bung T5/Bosch
$11,564.70
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail