$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x MTF0063 Manual Gear oil
1 x Rod Bearings only Pauter Rods
1 x 20th Viggen logo Shifter Top
2 x Oil Cap GM "HHR"
3 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Shifter Alignment Pins (Set 2)
1 x Griffin logo Shifter Top
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Injectors Green Giant 42lb (set 4)
2 x Crank Vent Kit #6 T7 4cyl
2 x IAT Weld Bung T5/Bosch
1 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x Exhaust Clamp Kit
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Map/MAT sensor weld bung
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Rear Camber Shims Kit 6pcs
1 x Limit Strap Coilover Add On Kit
1 x Machined Control Arm Kit
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Midpipe 2.8T FWD (2wd)
1 x Midpipe 2.8T XWD (4wd)
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
3 x BSR Optiflow Intake 4cyl
1 x Shift Rod Bushings
1 x Fuel Line Clip
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Metal Steering Wheel Buttons
1 x Headlight Bulb H7 Longer Life
1 x Mat Set Textile Parchment 9-5 10-
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Steering Coupler 9-3 99-02
1 x 9-5 Aero Sill Protection
1 x Shifter Mount Kit 93ss
1 x Open Air Intake 9000 93-98
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Antenna Plug NG900/9-3 hatchback
1 x 9-5 Textile Mats 98-07
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Hood Emblem 9-5 All
1 x Mass Airflow Meter T7
1 x Bulb Switch Light
2 x Oil Filter Re-locator
1 x ShortShift Kit 93ss
1 x 9-5 Shift Knobs Leather
1 x Mat Set Black Rubber 9-5 10-
1 x 9-3/NG900 Shift Knobs Leather
1 x Shifter Mount Kit Cobalt/ HHR
1 x Aero Clutch Kit 9-5
1 x Shifter Top Ghost Logo
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Oil Cooler Adaptor B2X5
2 x Hood Emblem 9-3 SS/sc 03- All
1 x ATF Saab 3309 (Automatic 02->)
1 x Air Filter 06 version (All 9-5)
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Coolant Bypass Valve 9-5
1 x Direct Ignition T7 Black
1 x Coreganizer
1 x Clear Little Fender Blinkers Factory Saab
1 x Front Rotors PAIR 302mm Plain (Code: AB)
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Cabin Vent Fan
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Direct Ignition T5 RED
1 x 4340 Connecting Rods B204 B235
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Head Bolt Washers
1 x PPC - Upgrade from stage 1 to stage 3
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
$12,778.93
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail