$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Alu Hybrid Flywheel For NG900/9-3
3 x Replacement Flywheel Insert NG900/9-3
3 x Quaife Differential 9-5 and Viggen (F35)
4 x Flywheel Twin Disk 7.25in B2xx
4 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Head Stud Kit all 4cyl
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Exhaust Clamp Kit
1 x Antenna Plug NG900/9-3 hatchback
1 x Cat back for Viggen 2.5in
1 x Fog light 9-3 left 99-00
1 x 9-3 /NG900 Grille
1 x T7 Head Plug NGK
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Con Rods V6 2.8L 155.8mm
2 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3 ng900 Hood Protection Strip
1 x Troll Head Plug
3 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
2 x B207 Coolant Cap
1 x Exhaust manifold Stud Kit
2 x ARP Exhaust Manifold Stud kit Stainless
2 x 9000 Shifter Bushing Repair Kit
1 x PPC 3 Volvo Diagnostic System
1 x Fuel Pressure Regulator 4.0 bar
1 x Basic Subframe Brace
1 x Clear Little Fender Blinkers Factory Saab
2 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x 3 Point Hardware
1 x Crush Sleeve F35 F25
1 x Oil Cooler Adaptor B2X5
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Brake Vac pump seals
1 x Rear Pedestal Spoiler 9-3 SS
1 x 4 Cyl 2.0 Coolant Tank
2 x Saab black Keychain
1 x BBS Center Cap for 9-2x RK small caps
1 x 9000 Intercooler ETS
1 x 9-5 Wheel 10-Spoke 16in.
2 x Floormats BSR 9-3 99-02 900 94-98
2 x 9-3 Rear Ashtray
3 x 20th Viggen logo Shifter Top
1 x 9-3/NG900 Shift Knobs Leather
4 x 9-3 ng900 radio wires
3 x Viggen Clutch Kit 99-02
3 x Transmission Nut F35 F25
2 x Shift Rod Bushings
2 x ARP Ring Gear Bolts F25/F35
1 x Rear Engine Mount 4cyl
2 x Aluminum Flywheel For NG900/9-3
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x BSR Optiflow Intake 4cyl
1 x Custom Brake Lines RR 300mm Kit
2 x Custom Brake Lines Brembo 315mm 9-3SS/SC
4 x Coreganizer
1 x BSR Optiflow Intake V6 2.8t
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Adaptor Harness Handsfree 01-
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Drop in Sport Filter 9-5
1 x Replacement Filter for Open air 9-3 T7
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x MTF0063 Manual Gear oil
2 x c900 Performance Brake lines
1 x Floormats BSR 9-3SS/SC
1 x BSR Optiflow Intake 4cyl w SAI
1 x v6 header flange
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Headbolts (New Style)
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
$23,810.36
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail