$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Open Air Intake 9-3 00-02 and Viggen (All T7)
4 x Viggen Fog Air Intake
5 x T7 Injector Spacer Kit
3 x T5 3.0 Bar Map Sensor Adaptor
1 x BSR 9-5 2010-2011 V6 300Hp
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Intake Flange B2x4 T5
2 x Head Bolt Washers
1 x Injectors Green Giant 42lb (set 4)
3 x BSR Optiflow Intake 4cyl
2 x AEM Wideband Gauge Kit
4 x 9-3 Rear Ashtray
4 x Griffin logo Shifter Top
3 x c900 Performance Brake lines
3 x 20th Viggen logo Shifter Top
4 x Clear Little Fender Blinkers Factory Saab
3 x Turbo Conversion Pipe 900 9-3 T5
7 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Fog light Replacement Panels
2 x 9-3 ng900 Hood Protection Strip
4 x Antenna Plug NG900/9-3 hatchback
4 x Oil Cooler Adaptor B2X5
1 x Fog light 9-3 Right 99-00
2 x 9-3 /NG900 Grille
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Machined Control Arm Kit
1 x T7 Head Plug NGK
1 x Viggen Titanium KeyChain
1 x Saab black Keychain
1 x SCNA Christmas Calendar
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Forge Bypass Valve Cobalt/HHR TC
2 x 9-5 Rear Brake rotor See Description
2 x 9-5 Aero Sill Protection
1 x Filter 9-5 Cabin Air
1 x 9-5 Open Air Prefilter
1 x "Griffin" Valve stem caps
2 x 9-5 Shift Knobs Leather
1 x Replacement V6 Coolant Cap
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-3 SS Akebono Rear Pads
1 x Upgrade Valve Springs T5 Cars
2 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Air Filter 06 version (All 9-5)
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
3 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x V6 Tank Float - SparePart
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x Aero Clutch Kit 9-5
1 x MTF0063 Manual Gear oil
1 x ATF Saab 3309 (Automatic 02->)
1 x Rivetnuts Pair (2pcs)
2 x Cat back for Viggen 2.5in
2 x Con Rods V6 2.8L 155.8mm
3 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
2 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
2 x Floormats BSR 9-5
1 x PPC 3 Volvo Diagnostic System
2 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x BSR Optiflow Replacement Filter V6 2.8
2 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x Floormats BSR 9-3SS/SC
2 x BSR 9-5 3.0T V6 200Hp
3 x Midpipe 2.0T 07-11 FWD (2wd)
2 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-5 Intercooler ETS
1 x Drop in Sport Filter 9-5
2 x PPC - Upgrade from stage 1 to stage 3
1 x Head Stud Kit all 4cyl
2 x Basic Subframe Brace
1 x Adaptor Harness Handsfree 01-
2 x 9-3 99-02,03 CV Antenna Adaptor
1 x Bulb Switch Light
1 x Throttle Bend for T5 94-99
1 x Shift Rod Bushings
1 x Front Camber Adjustment Bolts
1 x Headlight Bulb H7 Longer Life
1 x Headbolts (New Style)
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x Downpipe Hardware Kit
2 x Genuine Saab 4cyl Oil Filters
2 x Fuel Line Clip
1 x Brake Vac pump seals
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Oil Pressure Switch
1 x ShortShift Kit 93ss
1 x Shifter Mount Kit 93ss
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Rear spring perches Adjustable NG900/9-3
1 x Mat Set Black Rubber 9-5 10-
1 x Rear Camber Shims Kit 6pcs
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Mat Set Textile Jet Black 9-5 10-
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x Steering Rod Bushings NG900/93
1 x Front Camber Adjustment Bolts
2 x IAT Weld Bung T5/Bosch
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 9-3 ng900 radio wires
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
2 x Remote Button NG900
2 x Turbo Bypass Valve
2 x Throttle Body T7
1 x Exhaust Clamp Kit
2 x Replacement Hardware Pack 6-Point
1 x Rear Engine Mount 4cyl
1 x Mass Airflow Meter T7
1 x Replacement Filter for Open air 9-3 T7
1 x Direct Ignition T5 RED
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
3 x Universal / Special Request
1 x Fuel Pressure Regulator 4.0 bar
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Cigarette Lighter
1 x Steering Coupler 9-3 99-02
1 x Injectors Siemens 80lb 875cc (set 4)
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Rear Brake Pads 9-5 Later Style
1 x Fog light Replacement Panels 99-01
1 x BSR Optiflow Intake V6 2.8t
1 x 9-3/NG900 Shift Knobs Leather
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
$42,361.03
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail