$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

After doing the front install, I thought others would benefit from my mistakes. I installed the kit on a MY95 900.

Tools Needed:
Flat Blade screwdriver
11,14,17mm Socket
Jack and Jack Stands
Drain Pan
10mm Flare (Brake Line) Wrench
Channel Locks
7mm Allen (Hex) wrench
19,24mm Open-End Wrench
Torque Wrench

Jack up front of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (Flat blade and 17mm).

Place drain pan under caliper.

Remove banjo (from brake line to caliper) bolt, try to find the brass washers on both sides of the bolt (11mm socket).

Disconnect the solid brake line from flexible house, the 10mm little nut on top of the mounting tab not the 17mm on the bottom of the mounting tab. The 17mm can be used to hold the line in place if need be, I did not need to. (10mm flare wrench).

Remove clip securing the flexible line to the mounting point, slide the line out of the mounting point (channel locks).

Install new brake line to caliper, the fitting should be angled away from the caliper. Make sure to put a new brass washer on each side of the banjo bolt. Also, make sure the brake line does not interfere with accessing the caliper guide pin. (14mm socket, torque wrench, 7mm allen wrench).

Install new line into mounting point, hold bottom with 19mm wrench and tighten bolt with 24mm wrench (19,24mm wrench).

Install solid brake line into fitting on end of SS line (10mm flare wrench).

Bleed Brakes.

Re-install wheel/tire and lower vehicle.

I will write instructions for the rear lines as a separate review.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Shifter Mount Kit Cobalt/ HHR
5 x Short Shifter HHR Cobalt F35 F40
2 x Shifter Alignment Pins (Set 2)
1 x Con Rods V6 2.8L 155.8mm
1 x Troll Head Plug
1 x 9000 Shifter Bushing Repair Kit
1 x SCNA Christmas Calendar
1 x MTF0063 Manual Gear oil
1 x Replacement V6 Coolant Cap
1 x K&N Filter Service Kit
2 x ATF Saab 3309 (Automatic 02->)
2 x T7 Head Plug NGK
2 x Limit Strap Coilover Add On Kit
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Griffin logo Shifter Top
1 x PPC - Upgrade from stage 1 to stage 3
1 x Shifter Top Ghost Logo
1 x Direct Ignition T5 RED
1 x 4340 Connecting Rods B204 B235
2 x Oil Filter Re-locator
3 x Exhaust Clamp Kit
4 x Genuine Saab 4cyl Oil Filters
1 x Mass Airflow Meter T7
2 x Fuel Line Clip
4 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Headbolts (New Style)
1 x Replacement Flywheel Insert NG900/9-3
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Flywheel Twin Disk 7.25in B2xx
1 x JE Piston Rings 90.0mm 235/205
1 x Turbo Conversion Pipe 900 9-3 T5
2 x Antenna Plug NG900/9-3 hatchback
1 x Fog light 9-3 left 99-00
1 x Cat back for Viggen 2.5in
1 x Exhaust manifold Stud Kit
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Fog light 9-3 Right 99-00
1 x 9-3 ng900 Hood Protection Strip
2 x ARP Exhaust Manifold Stud kit Stainless
2 x 9-3 /NG900 Grille
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Fog light Replacement Panels
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
3 x Oil Cap GM "HHR"
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Shift Knobs Leather
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x c900 Performance Brake lines
1 x 9-5 Rear Brake rotor See Description
1 x Air Filter 06 version (All 9-5)
1 x 9-3/NG900 Shift Knobs Leather
2 x Clear Little Fender Blinkers Factory Saab
1 x Aero Clutch Kit 9-5
1 x IAT Weld Bung T5/Bosch
3 x Rear Camber Shims Kit 6pcs
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x 9-3 ng900 radio wires
2 x 20th Viggen logo Shifter Top
1 x Adaptor Harness Handsfree 01-
2 x 9-3 Rear Ashtray
1 x B207 Upper Radiator Coolant T
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Oil Cap 9-3SS "Ghost"
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Throttle Bend for T5 94-99
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Head Stud Kit all 4cyl
2 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x Custom Brake Lines RR 300mm Kit
1 x Upgrade Valve Springs T5 Cars
2 x 9-3 99-02,03 CV Antenna Adaptor
2 x 9-5 Open Air Prefilter
1 x Mat Set Textile Jet Black 9-5 10-
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Oil Cooler Adaptor B2X5
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Coreganizer
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Rear spring perches Adjustable NG900/9-3
1 x 9-3 SS Akebono Rear Pads
1 x Rear Rotors PAIR 292mm XWD (Code: BC)
1 x Rod Bearings only Pauter Rods
1 x Downpipe 2.8T FWD (2wd)
1 x Metal Steering Wheel Buttons
1 x Sparkplugs 9-3SS
1 x Slave Cyl
1 x Saab black Keychain
1 x Basic Subframe Brace
1 x Rear Brake Pads 9-3 SS
1 x 4 Cyl 2.0 Coolant Tank
$15,024.25
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail