$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Con Rods V6 2.8L 155.8mm
2 x Injectors Green Giant 42lb (set 4)
2 x IAT Weld Bung T5/Bosch
1 x Injectors Siemens 60lb 630cc (set 4)
2 x T5 3.0 Bar Map Sensor Adaptor
1 x AEM Wideband Gauge Kit
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Map/MAT sensor weld bung
2 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Head Bolt Washers
2 x Intake Flange B2x4 T5
2 x Fuel Pressure Regulator 4.0 bar
3 x PPC - Upgrade from stage 1 to stage 3
1 x Universal / Special Request
2 x Clear Little Fender Blinkers Factory Saab
2 x Short Shifter HHR Cobalt F35 F40
1 x PPC 3 Volvo Diagnostic System
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
3 x Fog light 9-3 left 99-00
1 x Fog light Replacement Panels
1 x Fog light 9-3 Right 99-00
2 x Cat back for Viggen 2.5in
3 x Exhaust manifold Stud Kit
6 x Exhaust Clamp Kit
2 x K&N Filter Service Kit
3 x MTF0063 Manual Gear oil
2 x ARP Exhaust Manifold Stud kit Stainless
2 x ATF Saab 3309 (Automatic 02->)
2 x Flex Pipe 900 94-98 9-3 99-02
2 x 9-3 ng900 Hood Protection Strip
1 x Floormats BSR 9-3 99-02 900 94-98
2 x 9-5 Blend Flap Limit Lever 99-04
2 x Direct Ignition T5 RED
3 x 20th Viggen logo Shifter Top
3 x 9-3 / 900 Uprated Front ARB Bushings
1 x Aluminum Flywheel For NG900/9-3
1 x 9-3/NG900 Shift Knobs Leather
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Genuine Saab 4cyl Oil Filters
4 x Crank Vent Kit #6 T7 4cyl
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Replacement Flywheel Insert NG900/9-3
1 x Rod Bearings only Pauter Rods
2 x Oil Filter Re-locator
2 x Direct Ignition T7 Black
2 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Remote Button NG900
2 x Downpipe Hardware Kit
2 x T7 Head Plug NGK
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x Quaife Differential 9-5 and Viggen (F35)
2 x 9-3 Rear Ashtray
2 x Rear Engine Mount 4cyl
4 x Transmission Nut F35 F25
1 x Crush Sleeve F35 F25
1 x Fuel Line Clip
1 x Mass Airflow Meter T7
2 x Replacement Hardware Pack 6-Point
1 x Shifter Top Ghost Logo
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
3 x Shift Rod Bushings
1 x 4340 Connecting Rods B204 B235
1 x Headbolts (New Style)
2 x Balance Shaft Tensioner Delete
1 x Replacement Filter for Open air 9-3 T7
1 x JE Piston Rings 90.0mm 235/205
2 x Coreganizer
2 x Adaptor Harness Handsfree 01-
2 x 9-3 99-02,03 CV Antenna Adaptor
2 x 9-3 ng900 radio wires
2 x Slave Cyl
2 x Alu Hybrid Flywheel For NG900/9-3
3 x Griffin logo Shifter Top
1 x Head Stud Kit all 4cyl
2 x Flywheel Twin Disk 7.25in B2xx
1 x ARP Ring Gear Bolts F25/F35
3 x Machined Control Arm Kit
2 x 9-5 Exhaust Flex Pipe Stainless
1 x Front Camber Adjustment Bolts
1 x Steering Coupler 9-3 99-02
2 x Basic Subframe Brace
1 x Rear Camber Shims Kit 6pcs
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Rear spring perches Adjustable NG900/9-3
1 x V6 Tank Float - SparePart
2 x 9-5 Aero Sill Protection
1 x Moog Ball Joint
1 x Saab black Keychain
1 x Oil Cap GM "HHR"
2 x v6oilcoolplate
3 x Brake Vac pump seals
1 x Oil Cap 9-3SS "Ghost"
1 x 9-5 Rear Brake rotor See Description
2 x Antenna Plug NG900/9-3 hatchback
2 x 9-5 Wheel 10-Spoke 16in.
2 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
3 x Throttle Bend for T5 94-99
1 x Shifter Mount Kit Cobalt/ HHR
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Shifter Alignment Pins (Set 2)
1 x Viggen Clutch Kit 99-02
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x T7 Injector Spacer Kit
1 x Turbo to Downpipe Flange B207
3 x Troll Head Plug
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
2 x Viggen Fog Air Intake
1 x Oil Cooler Adaptor B2X5
4 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x BSR 9-5 3.0T V6 200Hp
1 x SCNA Christmas Calendar
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x 9-5 High Performance Brake Line Kit
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Downpipe 2.8T XWD (4wd)
1 x B207 Upper Radiator Coolant T
1 x Rivetnuts Pair (2pcs)
1 x Coolant Bypass Valve 9-5
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Rear Brake Pads 9-5 Later Style
1 x Throttle Body T7
1 x Custom Brake Lines RR 300mm Kit
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
2 x Turbo Conversion Pipe 900 9-3 T5
1 x Rear Brake Pads 9-3 SS
1 x Sparkplugs 9-3SS
1 x v6 2.8t SAI Delete Kit
1 x v6 header flange
$30,371.84
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail