$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x K&N Filter Service Kit
4 x MTF0063 Manual Gear oil
2 x c900 Performance Brake lines
1 x Direct Ignition T7 Black
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Downpipe Hardware Kit
1 x T5 3.0 Bar Map Sensor Adaptor
2 x Fuel Pressure Regulator 4.0 bar
2 x Rivetnuts Pair (2pcs)
2 x Genuine Saab 4cyl Oil Filters
2 x Injectors Green Giant 42lb (set 4)
2 x Injectors Siemens 80lb 875cc (set 4)
2 x Mass Airflow Meter T7
1 x Head Bolt Washers
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
4 x IAT Weld Bung T5/Bosch
2 x Fuel Line Clip
2 x Injectors Siemens 60lb 630cc (set 4)
2 x PPC - Upgrade from stage 1 to stage 3
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Crank Vent Kit #6 T7 4cyl
2 x Exhaust Clamp Kit
1 x Replacement Filter for Open air 9-3 T7
2 x Universal / Special Request
2 x Direct Ignition T5 RED
2 x Moog Ball Joint
2 x Map/MAT sensor weld bung
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x PPC 3 Volvo Diagnostic System
1 x Replacement Flywheel Insert NG900/9-3
2 x Shift Rod Bushings
1 x Headbolts (New Style)
1 x SCNA Christmas Calendar
1 x Con Rods V6 2.8L 155.8mm
1 x T7 Head Plug NGK
1 x Replacement V6 Coolant Cap
1 x Limit Strap Coilover Add On Kit
2 x 9000 Shifter Bushing Repair Kit
1 x Troll Head Plug
1 x B207 Coolant Cap
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Short Shifter HHR Cobalt F35 F40
1 x Shifter Mount Kit Cobalt/ HHR
1 x 9-3 ng900 radio wires
2 x T7 Injector Spacer Kit
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-5 Aero Sill Protection
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 20th Viggen logo Shifter Top
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Shifter Alignment Pins (Set 2)
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Weld Bungs -Taper- Race Only
2 x Turbo Bypass Valve
1 x Rear Engine Mount 4cyl
1 x Crush Sleeve F35 F25
2 x Replacement Hardware Pack 6-Point
1 x Rear Pedestal Spoiler 9-3 SS
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Exhaust manifold Stud Kit
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x V6 Tank Float - SparePart
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x BSR Optiflow Intake 4cyl
1 x Flywheel Twin Disk 7.25in B2xx
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x Custom Brake Lines RR 300mm Kit
1 x Clear Little Fender Blinkers Factory Saab
2 x 9-5 Exhaust Flex Pipe Stainless
1 x Brembo Brake Kit 315mm 9-5 02-->
2 x Oil Cap 9-3SS "Ghost"
1 x Balance Shaft Tensioner Delete
1 x Griffin logo Shifter Top
1 x v6oilcoolplate
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Shifter Top Ghost Logo
1 x Drop in Sport Filter 9-5
1 x Oil Cap GM "HHR"
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Alu Hybrid Flywheel For NG900/9-3
$15,940.19
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail