$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x ATF Saab 3309 (Automatic 02->)
1 x Con Rods V6 2.8L 155.8mm
3 x Limit Strap Coilover Add On Kit
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x PPC 3 Volvo Diagnostic System
2 x Fog light Replacement Panels
1 x Cabin Vent Fan
2 x Genuine Saab 4cyl Oil Filters
1 x Mass Airflow Meter T7
2 x Air Filter 06 version (All 9-5)
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x Direct Ignition T7 Black
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Mat Set Textile Jet Black 9-5 10-
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x Open Air Intake 9000 93-98
1 x Mat Set Textile Shark Grey 9-5 10-
2 x Crush Sleeve F35 F25
3 x Shift Rod Bushings
1 x 9000 High Performance Brake Line Kit '95-'98
1 x 9000 Intercooler ETS
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Hood Emblem 9-5 All
2 x BSR 9-5 2010-2011 V6 300Hp
2 x 9-5 Intercooler ETS
1 x Troll Head Plug
2 x Rear Camber Shims Kit 6pcs
2 x Exhaust manifold Stud Kit
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Front Camber Adjustment Bolts
1 x Cigarette Lighter
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Drop in Sport Filter 9-5
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x 9-5 Shift Knobs Leather
1 x Bulb Switch Light
1 x ARP Exhaust Manifold Stud kit Stainless
2 x Aero Clutch Kit 9-5
2 x T7 Injector Spacer Kit
1 x K&N Filter Service Kit
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
4 x Clear Little Fender Blinkers Factory Saab
1 x T7 Head Plug NGK
4 x 9-5 Aero Sill Protection
1 x Adaptor Harness Handsfree 01-
1 x Slave Cyl
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x MTF0063 Manual Gear oil
1 x Floormats BSR 9-5
2 x Fog light Replacement Panels 99-01
2 x Shifter Alignment Pins (Set 2)
2 x 9-5 Textile Mats 98-07
1 x IAT Weld Bung T5/Bosch
1 x Intake Flange B2x4 T5
1 x Head Bolt Washers
1 x v6oilcoolplate
1 x Machined Control Arm Kit
1 x 9-3 ng900 radio wires
1 x 9-5 Exhaust Flex Pipe Stainless
1 x v6 header flange
1 x Brake Vac pump seals
1 x Flywheel Twin Disk 7.25in B2xx
1 x Griffin logo Shifter Top
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Oil Cap GM "HHR"
1 x Oil Cap 9-3SS "Ghost"
1 x 20th Viggen logo Shifter Top
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x B207 Upper Radiator Coolant T
2 x Oil Cooler Adaptor B2X5
2 x Basic Subframe Brace
1 x Injectors 175hp Stg3 (Set4)
2 x Steering Coupler 9-3 99-02
1 x Rod Bearings only Pauter Rods
1 x Fog light 9-3 left 99-00
1 x Filter 9-5 Cabin Air
1 x Valve Cover Gasket Set 4cyl
1 x 9-5 Open Air Prefilter
1 x Coolant Bypass Valve 9-5
2 x Storage Tray / Ashtray Kit 9-5 10-
1 x Replacement Filter for Open air 9-3 T7
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Downpipe Hardware Kit
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Throttle Bend for T5 94-99
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
$17,453.06
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail