$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Shifter Mount Kit Cobalt/ HHR
6 x 20th Viggen logo Shifter Top
4 x Short Shifter HHR Cobalt F35 F40
5 x Adaptor Harness Handsfree 01-
3 x Shifter Top Ghost Logo
5 x Shift Rod Bushings
4 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
4 x Aluminum Flywheel For NG900/9-3
5 x Flywheel Twin Disk 7.25in B2xx
1 x Balance Shaft Tensioner Delete
3 x Oil Filter Re-locator
1 x 4340 Connecting Rods B204 B235
2 x Headbolts (New Style)
1 x Upgrade Valve Springs T5 Cars
2 x JE Piston Rings 90.0mm 235/205
3 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x T5 3.0 Bar Map Sensor Adaptor
2 x Fog light Replacement Panels
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Con Rods V6 2.8L 155.8mm
1 x Direct Ignition T5 RED
1 x SCNA Christmas Calendar
1 x 9000 Shifter Bushing Repair Kit
1 x Direct Ignition T7 Black
1 x Replacement Filter for Open air 9-3 T7
1 x Mass Airflow Meter T7
1 x MTF0063 Manual Gear oil
1 x Exhaust Clamp Kit
1 x K&N Filter Service Kit
1 x Replacement V6 Coolant Cap
3 x T7 Head Plug NGK
1 x B207 Coolant Cap
2 x Replacement Hardware Pack 6-Point
1 x Limit Strap Coilover Add On Kit
2 x Fuel Line Clip
1 x Crush Sleeve F35 F25
1 x Remote Button NG900
1 x Shifter Alignment Pins (Set 2)
2 x Downpipe Hardware Kit
1 x Rear spring perches Adjustable NG900/9-3
1 x 9-5 Aero Sill Protection
1 x 9-3 ng900 radio wires
1 x Coreganizer
3 x 9-3 Rear Ashtray
1 x 9-3/NG900 Shift Knobs Leather
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x Rear Engine Mount 4cyl
1 x Slave Cyl
1 x Viggen Clutch Kit 99-02
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x 9-5 Blend Flap Limit Lever 99-04
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Troll Head Plug
2 x Throttle Bend for T5 94-99
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Rear Camber Shims Kit 6pcs
2 x Machined Control Arm Kit
1 x Turbo Bypass Valve
2 x Fog light 9-3 left 99-00
1 x 9-3 ng900 Hood Protection Strip
1 x 9-3 /NG900 Grille
1 x Clear Little Fender Blinkers Factory Saab
1 x Floormats BSR 9-3 99-02 900 94-98
2 x Oil Cooler Adaptor B2X5
1 x Viggen Fog Air Intake
2 x Turbo Conversion Pipe 900 9-3 T5
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Viggen Front Brake Disk Pair 308mm
3 x Weld Bungs -Taper- Race Only
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Injectors Siemens 60lb 630cc (set 4)
2 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Universal / Special Request
1 x Rivetnuts Pair (2pcs)
1 x IAT Weld Bung T5/Bosch
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Moog Ball Joint
2 x Intake Flange B2x4 T5
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Map/MAT sensor weld bung
2 x Head Bolt Washers
1 x BBS Center Cap for 9-2x RK small caps
2 x Griffin logo Shifter Top
1 x Fog light Replacement Panels 99-01
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Brembo Brake Kit 315mm 9-3 SS
1 x Head Stud Kit all 4cyl
1 x PPC - Upgrade from stage 1 to stage 3
1 x 9-5 High Performance Brake Line Kit
1 x Alu Hybrid Flywheel For NG900/9-3
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Transmission Nut F35 F25
2 x Replacement Flywheel Insert NG900/9-3
1 x Crank Vent Kit #6 T7 4cyl
$22,521.40
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail