$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x 20th Viggen logo Shifter Top
3 x 9-3 / 900 Uprated Front ARB Bushings
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
4 x Balance Shaft Tensioner Delete
3 x Head Stud Kit all 4cyl
1 x 4340 Connecting Rods B204 B235
3 x Direct Ignition T5 RED
3 x Crush Sleeve F35 F25
4 x JE Piston Ring (1cyl) 90.5mm 235/205/204
4 x Rod Bearings only Pauter Rods
3 x JE Piston Rings 90.0mm 235/205
5 x Upgrade Valve Springs T5 Cars
2 x Exhaust Clamp Kit
3 x Oil Filter Re-locator
3 x Fuel Pressure Regulator 4.0 bar
3 x AEM Wideband Gauge Kit
4 x Head Bolt Washers
6 x Injectors Green Giant 42lb (set 4)
3 x Universal / Special Request
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
4 x PPC - Upgrade from stage 1 to stage 3
1 x Oil Cap GM "HHR"
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Short Shifter HHR Cobalt F35 F40
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x K&N Filter Service Kit
2 x ATF Saab 3309 (Automatic 02->)
2 x B207 Coolant Cap
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Shifter Top Ghost Logo
2 x Alu Hybrid Flywheel For NG900/9-3
1 x Flywheel Twin Disk 7.25in B2xx
1 x Rear Camber Shims Kit 6pcs
1 x Steering Coupler 9-3 99-02
1 x Aluminum Flywheel For NG900/9-3
1 x Midpipe 2.0T 07-11 FWD (2wd)
4 x Shift Rod Bushings
2 x Shifter Alignment Pins (Set 2)
1 x Turbo to Downpipe Flange B207
1 x Downpipe 2.8T XWD (4wd)
2 x 9-5 Aero Sill Protection
2 x Throttle Body T7
4 x T7 Head Plug NGK
1 x Rear Engine Mount 4cyl
2 x Mass Airflow Meter T7
2 x Turbo Bypass Valve
1 x Coreganizer
1 x Griffin logo Shifter Top
3 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 Rear Ashtray
1 x 9-3/NG900 Shift Knobs Leather
3 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-3 ng900 radio wires
1 x Adaptor Harness Handsfree 01-
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x 9-5 Wheel 5-Spoke Twin 17in
3 x Injectors Siemens 60lb 630cc (set 4)
1 x 9-5 Wheel 10-Spoke 16in.
1 x Headbolts (New Style)
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
3 x IAT Weld Bung T5/Bosch
2 x Weld Bungs -Taper- Race Only
2 x Injectors Siemens 80lb 875cc (set 4)
3 x Rivetnuts Pair (2pcs)
1 x BBS Center Cap for 9-2x RK small caps
2 x Moog Ball Joint
2 x T5 3.0 Bar Map Sensor Adaptor
2 x Fog light 9-3 Right 99-00
2 x 9-3 /NG900 Grille
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Viggen Fog Air Intake
1 x Clear Little Fender Blinkers Factory Saab
1 x Aero Clutch Kit 9-5
1 x Con Rods V6 2.8L 155.8mm
1 x 9-5 Textile Mats 98-07
1 x Transmission Nut F35 F25
1 x ARP Ring Gear Bolts F25/F35
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Air Filter 06 version (All 9-5)
2 x Downpipe Hardware Kit
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Replacement V6 Coolant Cap
1 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9000 High Performance Brake Line Kit '95-'98
1 x ARP Exhaust Manifold Stud kit Stainless
1 x 9000 Intercooler ETS
1 x 9000 Shifter Bushing Repair Kit
1 x Open Air Intake 9000 93-98
1 x Troll Head Plug
2 x Replacement Filter for Open air 9-3 T7
1 x Flex Pipe 900 94-98 9-3 99-02
2 x Crank Vent Kit #6 T7 4cyl
1 x Replacement Hardware Pack 6-Point
1 x Genuine Saab 4cyl Oil Filters
1 x Intake Flange B2x4 T5
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Hood Emblem 9-5 All
1 x Viggen Clutch Kit 99-02
1 x MTF0063 Manual Gear oil
1 x Basic Subframe Brace
$25,963.39
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail