$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x T7 Injector Spacer Kit
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x Turbo Conversion Pipe 900 9-3 T5
3 x c900 Performance Brake lines
5 x Clear Little Fender Blinkers Factory Saab
2 x 9-3 ng900 radio wires
3 x 9-3 Rear Ashtray
2 x 20th Viggen logo Shifter Top
2 x MTF0063 Manual Gear oil
2 x Exhaust manifold Stud Kit
2 x K&N Filter Service Kit
3 x Shifter Alignment Pins (Set 2)
1 x ARP Exhaust Manifold Stud kit Stainless
3 x Cat back for Viggen 2.5in
1 x ATF Saab 3309 (Automatic 02->)
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Injectors Green Giant 42lb (set 4)
1 x Headbolts (New Style)
1 x SCNA Christmas Calendar
2 x AEM Wideband Gauge Kit
2 x Troll Head Plug
1 x 9-3 /NG900 Grille
2 x Direct Ignition T7 Black
1 x Genuine Saab 4cyl Oil Filters
1 x Direct Ignition T5 RED
1 x Remote Button NG900
1 x Crank Vent Kit #6 T7 4cyl
1 x Mass Airflow Meter T7
1 x Fuel Line Clip
1 x Short Shifter HHR Cobalt F35 F40
1 x Oil Cap GM "HHR"
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Hood Emblem 9-5 All
1 x Headlight Bulb H7 Longer Life
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x 9-5 Blend Flap Limit Lever 99-04
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 / 900 Uprated Front ARB Bushings
3 x Viggen Fog Air Intake
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x Floormats BSR 9-3 99-02 900 94-98
1 x PPC 3 Volvo Diagnostic System
1 x Coreganizer
1 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3/NG900 Shift Knobs Leather
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Oil Filter Re-locator
1 x v6 header flange
1 x 9000 Shifter Bushing Repair Kit
1 x 9000 Intercooler ETS
1 x Rod Bearings only Pauter Rods
1 x Fuel Pressure Regulator 4.0 bar
1 x T7 Head Plug NGK
2 x Weld Bungs -Taper- Race Only
2 x Head Bolt Washers
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Map/MAT sensor weld bung
1 x Aero Clutch Kit 9-5
1 x Head Stud Kit all 4cyl
1 x 9-5 Aero Sill Protection
1 x Adaptor Harness Handsfree 01-
2 x Throttle Bend for T5 94-99
1 x Replacement V6 Coolant Cap
1 x Moog Ball Joint
1 x Downpipe Hardware Kit
1 x Oil Cap 9-3SS V6 "Ghost"
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Basic Subframe Brace
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Oil Cooler Adaptor B2X5
1 x Balance Shaft Tensioner Delete
1 x Rear spring perches Adjustable NG900/9-3
1 x Custom Brake Lines RR 300mm Kit
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x v6oilcoolplate
1 x Shift Rod Bushings
1 x Limit Strap Coilover Add On Kit
1 x IAT Weld Bung T5/Bosch
$16,762.65
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail