$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Rear Pedestal Spoiler 9-3 SS
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
2 x PPC - Upgrade from stage 1 to stage 3
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
3 x Floormats BSR 9-3SS/SC
4 x Coreganizer
4 x Shifter Alignment Pins (Set 2)
1 x Troll Head Plug
1 x Replacement V6 Coolant Cap
2 x SCNA Christmas Calendar
3 x Clear Little Fender Blinkers Factory Saab
2 x 3 Point Hardware
1 x Viggen Titanium KeyChain
3 x Saab black Keychain
1 x v6 header flange
2 x BSR Optiflow Replacement Filter V6 2.8
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x BSR Optiflow Intake 4cyl w SAI
1 x Con Rods V6 2.8L 155.8mm
3 x ShortShift Kit 93ss
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Oil Filter Re-locator
2 x 9-5 Aero Sill Protection
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Aero Clutch Kit 9-5
2 x 9-3 ng900 Hood Protection Strip
1 x 9-3/NG900 Shift Knobs Leather
1 x Basic Subframe Brace
1 x Metal Steering Wheel Buttons
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-5 Rear Brake rotor See Description
2 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
2 x BSR 9-5 2010-2011 V6 300Hp
1 x Mat Set Textile Parchment 9-5 10-
2 x Replacement Hardware Pack 6-Point
2 x Alu Hybrid Flywheel For NG900/9-3
3 x Fog light Replacement Panels
3 x Rear Engine Mount 4cyl
2 x Oil Cooler Adaptor B2X5
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Mass Airflow Meter T7
1 x Machined Control Arm Kit
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Exhaust Clamp Kit
2 x Remote Button NG900
1 x Fuel Line Clip
2 x IAT Weld Bung T5/Bosch
1 x 9-3 ng900 radio wires
1 x Hood Emblem 9-5 All
3 x Crush Sleeve F35 F25
4 x 9000 Shifter Bushing Repair Kit
2 x 9000 High Performance Brake Line Kit '95-'98
3 x Shifter Mount Kit Cobalt/ HHR
1 x Oil Cap GM "HHR"
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Adaptor Harness Handsfree 01-
3 x K&N Filter Service Kit
2 x BBS Center Cap for 9-2x RK small caps
1 x ATF Saab 3309 (Automatic 02->)
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Upgrade Valve Springs T5 Cars
1 x Mat Set Textile Shark Grey 9-5 10-
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x Valve Cover Gasket Set 4cyl
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Viggen Front Brake Disk Pair 308mm
2 x Storage Tray / Ashtray Kit 9-5 10-
1 x Viggen Clutch Kit 99-02
2 x Rear Rotors PAIR 292mm XWD (Code: BC)
1 x Turbo Bypass Valve
2 x Slave Cyl
1 x Headlight Bulb H7 Longer Life
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Direct Ignition T7 Black
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Genuine Saab 4cyl Oil Filters
1 x Injectors 175hp Stg3 (Set4)
1 x v6oilcoolplate
1 x Shifter Mount Kit 93ss
2 x MTF0063 Manual Gear oil
1 x 9-5 High Performance Brake Line Kit
1 x c900 Performance Brake lines
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x ARP Ring Gear Bolts F25/F35
1 x Transmission Nut F35 F25
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x 9-5 Wheel 10-Spoke 16in.
1 x Drop in Sport Filter 9-5
1 x Front Camber Adjustment Bolts
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Steering Rod Bushings NG900/93
2 x Short Shifter HHR Cobalt F35 F40
2 x Steering Coupler 9-3 99-02
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Shifter Top Ghost Logo
1 x Fog light 9-3 left 99-00
2 x Shift Rod Bushings
1 x Limit Strap Coilover Add On Kit
1 x T7 Injector Spacer Kit
1 x Viggen Fog Air Intake
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Antenna Plug NG900/9-3 hatchback
1 x Custom Brake Lines RR 300mm Kit
2 x Forge Bypass Valve Cobalt/HHR TC
1 x Rivetnuts Pair (2pcs)
2 x Exhaust manifold Stud Kit
1 x 9000 Intercooler ETS
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Downpipe Hardware Kit
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9-5 Open Air Prefilter
1 x Open Air Intake 9000 93-98
1 x Injectors Green Giant 42lb (set 4)
1 x Replacement Flywheel Insert NG900/9-3
1 x Fog light 9-3 Right 99-00
1 x 9-3 Rear Ashtray
1 x Map/MAT sensor weld bung
1 x Griffin logo Shifter Top
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Rear Camber Shims Kit 6pcs
$28,133.56
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail