$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Injectors Siemens 60lb 630cc (set 4)
2 x T5 3.0 Bar Map Sensor Adaptor
3 x Injectors Siemens 80lb 875cc (set 4)
4 x PPC - Upgrade from stage 1 to stage 3
2 x Injectors Green Giant 42lb (set 4)
4 x SCNA Christmas Calendar
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
4 x Clear Little Fender Blinkers Factory Saab
1 x Balance Shaft Tensioner Delete
2 x Rod Bearings only Pauter Rods
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Mass Airflow Meter T7
3 x Flex Pipe 900 94-98 9-3 99-02
1 x Direct Ignition T5 RED
2 x Throttle Bend for T5 94-99
2 x Quaife Differential 9-5 and Viggen (F35)
2 x Direct Ignition T7 Black
3 x Rear Engine Mount 4cyl
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Fog light 9-3 left 99-00
1 x T7 Injector Spacer Kit
2 x Aluminum Flywheel For NG900/9-3
2 x Downpipe Hardware Kit
2 x Antenna Plug NG900/9-3 hatchback
1 x Exhaust manifold Stud Kit
2 x ARP Exhaust Manifold Stud kit Stainless
3 x Exhaust Clamp Kit
1 x Crank Vent Kit #6 T7 4cyl
1 x Shifter Top Ghost Logo
2 x Transmission Nut F35 F25
2 x Crush Sleeve F35 F25
1 x Replacement Flywheel Insert NG900/9-3
1 x Fog light 9-3 Right 99-00
1 x Genuine Saab 4cyl Oil Filters
1 x Remote Button NG900
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Replacement Filter for Open air 9-3 T7
2 x Viggen Fog Air Intake
3 x Shift Rod Bushings
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Cat back for Viggen 2.5in
1 x Griffin logo Shifter Top
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-3 ng900 radio wires
1 x 9-3/NG900 Shift Knobs Leather
2 x Adaptor Harness Handsfree 01-
4 x Coreganizer
1 x 9-3 Rear Ashtray
1 x Floormats BSR 9-3 99-02 900 94-98
1 x B207 Upper Radiator Coolant T
1 x V6 Tank Float - SparePart
1 x Hood Emblem 9-3 SS/sc 03- All
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x Front Camber Adjustment Bolts
3 x ShortShift Kit 93ss
2 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Optical Cable Connector (Onstar Delete)
1 x 3 Point Hardware
2 x Shifter Mount Kit 93ss
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
3 x Weld Bungs -Taper- Race Only
1 x Rear Pedestal Spoiler 9-3 SS
1 x Sparkplugs 9-3SS
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x Brake Vac pump seals
3 x AEM Wideband Gauge Kit
2 x Metal Steering Wheel Buttons
1 x Head Bolt Washers
1 x Map/MAT sensor weld bung
3 x Slave Cyl
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Aero Clutch Kit 9-5
1 x Forge Bypass Valve Cobalt/HHR TC
1 x BBS Center Cap for 9-2x RK small caps
2 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x ATF Saab 3309 (Automatic 02->)
1 x MTF0063 Manual Gear oil
1 x Shifter Alignment Pins (Set 2)
3 x Saab black Keychain
1 x ARP Ring Gear Bolts F25/F35
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Flywheel Twin Disk 7.25in B2xx
1 x Replacement Hardware Pack 6-Point
1 x Oil Cooler Adaptor B2X5
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Replacement V6 Coolant Cap
1 x Steering Coupler 9-3 99-02
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Oil Cap 9-3SS "Ghost"
1 x BSR Optiflow Intake V6 2.8t
2 x 4340 Connecting Rods B204 B235
1 x Floormats BSR 9-3SS/SC
1 x Steering Rod Bushings NG900/93
1 x 9-5 Shift Knobs Leather
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Turbo to Downpipe Flange B207
1 x BSR Optiflow Intake 4cyl w SAI
1 x BSR Optiflow Intake 4cyl
1 x BSR Optiflow Replacement Filter V6 2.8
1 x v6 2.8t SAI Delete Kit
2 x K&N Filter Service Kit
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x 9-5 Intercooler ETS
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
$29,226.95
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail